|
|
|
|
|
|
| |
Automobile Manufacturer Recall Data - Gmc Recalls 
Posted: 08-15-2008 | |
| 1500 ACADIA CANYON ENVOY ENVOY XL GMT 560 JIMMY SAVANA SAVANA 1500 SAVANA VAN SIERRA SIERRA DENALI SONOMA T-SERIES TOPKICK TOPKICK 6500 TOPKICK 8500 W3500 W4500 W5500 YUKON YUKON XL | |
| 1500 RECALLS | Top |
| 2004 GMC 1500 Manufactured between: 01/29/2004 and 05/12/2004 Defect: the spare tire and wheel assembly that was provided on certain conversion vehicles will not fit on the front wheel hub due to offset of the wheel. however, it will fit on the rear wheels. Consequence: if someone has a flat tire on the front wheel, they will not be able to install the provided spare tire. Action: dealers will install a spare wheel with the correct offset. owner notification began on june 11, 2004. owners should contact regency at 1-800-989-4727. Recall Date: 05/17/2004 | |
| ACADIA RECALLS | Top |
| 2007 GMC ACADIA Manufactured between: 09/01/2006 and 02/16/2007 Defect: on certain vehicles, the sensing and diagnostic module (sdm), which controls the function of front air bags, may not operate properly. as a result, the front air bags may fail to deploy in a frontal crash. also, the air bag warning lamp on the instrument panel may fail to provide warning that the system is inoperative. Consequence: in the event of a crash, this condition could increase the risk of injury to occupants in the front seat. Action: dealers will reprogram the sdm computer module. this recall began on february 22, 2007. owners may contact gmc at 1-866-966-9463 or saturn at 1-800-972-8876. Recall Date: 02/21/2007 | |
| CANYON RECALLS | Top |
| 2007 GMC CANYON Manufactured between: 04/01/2006 and 05/31/2006 Defect: certain sport utility vehicles and trucks fail to comply with the requirements of federal motor vehicle safety standard no. 110, ¿tire selection and rims." these vehicles have an incomplete tire rim designation on the certification/tire label located on the driver's door edge. in addition, the label may also be missing the tire load rating on the label. although this information is not required by the standard, if a tire of a lesser load rating is installed, the tire may not be able to sustain the loads encountered during use. Consequence: if a customer replaces a wheel and only relies on the rim size designation that is indicated on the label, a wheel that is of a different rim contour designation may be installed. it may be difficult or impossible to mount the tire on a wheel with the wrong contour. if the tire is mounted on the wheel with the wrong contour, the wheel and tire may not perform as intended, which could increase the risk of a crash. Action: a label that will correct the label originally installed will be mailed to consumers along with installation instructions. the customer will have the option for dealers to install the label. the recall begaon on november 7, 2006. owners should contact cadillac at 1-866-982-2239, chevrolet at 1-800-630-2438, and gmc trucks at 1-866-996-9463. Recall Date: 08/11/2006 | |
| 2006 GMC CANYON Manufactured between: 04/01/2005 and 04/11/2006 Defect: certain pickup trucks may experience the permanent loss of brake lamp function or brake lamps that are illuminated at all times. the center high-mounted stop lamp (chmsl) is affected in both instances. also, if equipped, the cruise control will become inoperative. any trailer brake lamps which are connected to the vehicle's brake lamp wiring will mimic the vehicle's brake lamps when either condition occurs. Consequence: a following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning. Action: dealers will replace the brake lamp switch assembly. the recall began on december 5, 2006. owners may contact chevrolet at 1-800-630-2438; gmc at 1-866-996-9463 or isuzu at 1-800-255-6727. Recall Date: 04/27/2006 | |
| 2006 GMC CANYON Manufactured between: 09/01/2005 and 09/07/2005 Defect: certain trucks and sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims.¿ these vehicles were shipped with tire and loading information labels listing an inacccurate vehicle capacity weight. Consequence: a misprinted label could lead to improper vehicle loading specifications or tire inflation which could result in a tire failure, increasing the risk of a crash. Action: owners will be provided with corrected labels and installation instructions. at the customer¿s option, a dealer can install the label for them. the recall began on march 31, 2006. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, hummer at 1-800-732-5493, pontiac at 1-800-620-7668, saturn at 1-800-972-8876, or isuzu at 1-800-255-6727. Recall Date: 12/07/2005 | |
| 2005 GMC CANYON Manufactured between: 04/01/2004 and 06/30/2005 Defect: certain pickup trucks may experience the permanent loss of brake lamp function or brake lamps that are illuminated at all times. the center high-mounted stop lamp (chmsl) is affected in both instances. also, if equipped, the cruise control will become inoperative. any trailer brake lamps which are connected to the vehicle's brake lamp wiring will mimic the vehicle's brake lamps when either condition occurs. Consequence: a following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning. Action: dealers will replace the brake lamp switch assembly. the recall began on december 5, 2006. owners may contact chevrolet at 1-800-630-2438; gmc at 1-866-996-9463 or isuzu at 1-800-255-6727. Recall Date: 04/27/2006 | |
| 2004 GMC CANYON Manufactured between: 06/01/2003 and 06/30/2004 Defect: certain pickup trucks may experience the permanent loss of brake lamp function or brake lamps that are illuminated at all times. the center high-mounted stop lamp (chmsl) is affected in both instances. also, if equipped, the cruise control will become inoperative. any trailer brake lamps which are connected to the vehicle's brake lamp wiring will mimic the vehicle's brake lamps when either condition occurs. Consequence: a following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning. Action: dealers will replace the brake lamp switch assembly. the recall began on december 5, 2006. owners may contact chevrolet at 1-800-630-2438; gmc at 1-866-996-9463 or isuzu at 1-800-255-6727. Recall Date: 04/27/2006 | |
| ENVOY RECALLS | Top |
| 2006 GMC ENVOY Manufactured between: 07/01/2005 and 08/31/2005 Defect: certain vehicles originally built with cloth seats that were equipped with an automatic air bag passenger sensing system and later reupholstered with aftermarket leather seat cover kits are involved. testing has indicated that the aftermarket leather seat covers can cause the passenger sensing system to malfunction. Consequence: if the passenger sensing system malfunctions, the front air bag on the passenger side may be disabled when it should be enabled, or enabled when it should be disabled. in either case, in the event of a crash that requires air bag deployment, a front passenger's level of injury may be increased. Action: because a replacement leather seat cover that is compatible with the passenger sensing system is not available, general motors (gm) will repurchase these vehicles in accordance with the terms stated in gm¿s letter to owners. the recall began on november 6, 2006. owners should contact gm at 1-877-477-1022 to begin the process of repurchasing their vehicle. Recall Date: 10/31/2006 | |
| 2006 GMC ENVOY Manufactured between: 09/01/2005 and 09/07/2005 Defect: certain trucks and sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims.¿ these vehicles were shipped with tire and loading information labels listing an inacccurate vehicle capacity weight. Consequence: a misprinted label could lead to improper vehicle loading specifications or tire inflation which could result in a tire failure, increasing the risk of a crash. Action: owners will be provided with corrected labels and installation instructions. at the customer¿s option, a dealer can install the label for them. the recall began on march 31, 2006. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, hummer at 1-800-732-5493, pontiac at 1-800-620-7668, saturn at 1-800-972-8876, or isuzu at 1-800-255-6727. Recall Date: 12/07/2005 | |
| 2006 GMC ENVOY Manufactured between: 07/01/2005 and 08/31/2005 Defect: certain passenger vehicles may have been built with a power steering hose that is not to specification. under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid. Consequence: if this were to occur, power steering assist would be lost and increased steering effort would be required. on vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. if the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur. Action: dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. the recall will begin on october 14, 2005. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493. Recall Date: 10/05/2005 | |
| 2005 GMC ENVOY Manufactured between: 08/01/2004 and 06/30/2005 Defect: certain vehicles originally built with cloth seats that were equipped with an automatic air bag passenger sensing system and later reupholstered with aftermarket leather seat cover kits are involved. testing has indicated that the aftermarket leather seat covers can cause the passenger sensing system to malfunction. Consequence: if the passenger sensing system malfunctions, the front air bag on the passenger side may be disabled when it should be enabled, or enabled when it should be disabled. in either case, in the event of a crash that requires air bag deployment, a front passenger's level of injury may be increased. Action: because a replacement leather seat cover that is compatible with the passenger sensing system is not available, general motors (gm) will repurchase these vehicles in accordance with the terms stated in gm¿s letter to owners. the recall began on november 6, 2006. owners should contact gm at 1-877-477-1022 to begin the process of repurchasing their vehicle. Recall Date: 10/31/2006 | |
| 2005 GMC ENVOY Manufactured between: 11/03/2004 and 12/07/2004 Defect: certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 212, 'windshield mounting.' the windshield urethane bead may not have adhered to the body in certain areas during the cure process. Consequence: if a crash occurs, the windshield may not be retained, increasing the risk of injury to a vehicle occupant. Action: dealers will replace the windshield free of charge. the recall began on march 10, 2005. owners may contact buick at 1-866-608-8080, chevrolet at 1-800-630-2438, or gmc at 1-866-996-9463. Recall Date: 02/03/2005 | |
| 2004 GMC ENVOY Manufactured between: 04/01/2003 and 11/30/2003 Defect: on certain trucks and sport utility vehicles, the driver wishing to signal a turn by moving the directional signal lever, (up or down) may cause the front marker/turn lights and rear turn lights to flash in a manner similar to hazard warning, rather than flashing on the desired side only. Consequence: the driver may not be able to clearly signal their intentions to turn, change travel lanes, or potentially warn others of an impaired vehicle operating condition increasing the risk of a crash. Action: dealers will replace the suspect flasher modules with a new flasher module designed with sealed relays and more durable contact material inside of the relays free of charge. the recall began on august 4, 2005. isuzu began mailing owner letters on august 4, 2005. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, isuzu at 1-800-255-6727, buick at 1-866-608-8080, and oldsmobile at 1-800-630-6537. Recall Date: 05/05/2005 | |
| ENVOY XL RECALLS | Top |
| 2006 GMC ENVOY XL Manufactured between: 07/01/2005 and 08/31/2005 Defect: certain passenger vehicles may have been built with a power steering hose that is not to specification. under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid. Consequence: if this were to occur, power steering assist would be lost and increased steering effort would be required. on vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. if the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur. Action: dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. the recall will begin on october 14, 2005. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493. Recall Date: 10/05/2005 | |
| 2004 GMC ENVOY XL Manufactured between: 04/01/2003 and 08/31/2003 Defect: on certain sport utility vehicles, vibration and heat may cause the tail lamp/stop lamp bulb to loosen in its socket. if this occurs, the bulb may flicker and eventually become inoperative. Consequence: an inoperative brake lamp will not convey the driver's intention of stopping to drivers in following vehicles, and an inoperative rear turn signal lamp will not convey the driver¿s intention to turn to drivers in following vehicles. both of these failures can increase the risk of a crash. Action: dealers will inspect the tail lamp/stop lamp assemblies, and if necessary, replace them. the recall began on november 22, 2004. owners should contact chevrolet at 1-800-630-2438, oldsmobile at 1-800-630-6537, buick at 1-866-608-8080, or gmc at 1-866-996-9463. Recall Date: 11/01/2004 | |
| GMT 560 RECALLS | Top |
| 2005 GMC GMT 560 Manufactured between: 05/04/2004 and 02/16/2005 Defect: certain medium duty conventional cab trucks were produced with a body wiring harness with no protective conduit in the area under the driver's feet to reduce the potential for harness wear. the body wiring harness includes sdm wiring that could be damaged from chafing and wear by the vehicle operator. Consequence: this could result in inadvertent air bag deployment. a person may receive minor injuries, such as abrasions, from contact with the bag. Action: dealers will inspect the wiring harness for potential damage, repair or replace the harness if required, and add conduit to all harnesses free of charge. the recall begaon on may 3, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 03/18/2005 | |
| 2004 GMC GMT 560 Manufactured between: 05/23/2003 and 06/28/2004 Defect: certain medium duty conventional cab trucks were produced with a body wiring harness with no protective conduit in the area under the driver's feet to reduce the potential for harness wear. the body wiring harness includes sdm wiring that could be damaged from chafing and wear by the vehicle operator. Consequence: this could result in inadvertent air bag deployment. a person may receive minor injuries, such as abrasions, from contact with the bag. Action: dealers will inspect the wiring harness for potential damage, repair or replace the harness if required, and add conduit to all harnesses free of charge. the recall begaon on may 3, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 03/18/2005 | |
| JIMMY RECALLS | Top |
| 2004 GMC JIMMY Manufactured between: 04/01/2003 and 02/29/2004 Defect: certain pickup trucks and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 208, ¿occupant crash protection.¿ Consequence: some of these vehicles include incorrect statements on one of the air bag warning labels. Action: owners will be provided with correct labels and installation instructions. owner notification began on june 4, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 03/18/2004 | |
| SAVANA RECALLS | Top |
| 2008 GMC SAVANA Manufactured between: 06/01/2008 and 07/31/2008 Defect: gm is recalling 151 my 2008 chevrolet express and gmc savana vehicles equipped with all wheel drive (awd). some of these vehicles have transfer cases that were manufactured with an incorrect part that can cause early failure of a drive chain. if the chain breaks, shifting the transmission to park may not keep the vehicle stationary. Consequence: if the vehicle is parked on an incline or bumped, it may roll and strike a person, object, or another vehicle without warning, and cause personal injury. Action: dealers will inspect the transfer case date code and, if necessary, replace the transfer case. the recall is expected to begin on or about august 15, 2008. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 07/28/2008 | |
| 2008 GMC SAVANA Manufactured between: 09/01/2007 and 05/30/2008 Defect: gm is recalling 2,481 my 2008 chevrolet express and gmc savana g-cutaway fleet van equipped with a 6.0l (rpo ly6) v8 engine, 4l80e (rpo mt1) transmission, 4.10 (rpo gt5) axle and 75 mph governor (rpo 9d7). these vehicles have a condition in which the transmission may be damaged due to first gear engagement at highway speeds and then does not transmit power with d4 or r selected. this may be preceded by engine shutdown if the vehicle exceeds 81 miles per hour in certain conditions. Consequence: the vehicle may be stranded on or near a highway, increasing the risk of a crash. Action: dealers will reprogram the transmission and engine control modules free of charge. the recall is expected to begin on or about july 30, 2008. owners may contact chevrolet at 1-800-630-2438 and gmc at 1-866-996-9463. Recall Date: 07/11/2008 | |
| 2006 GMC SAVANA Manufactured between: 04/01/2005 and 10/31/2005 Defect: gm is recalling 4,003 my 2006 chevrolet express and gmc savana full-size passenger, cargo, or cutaway vans. the front and rear seat belt buckles will not latch or will not unlatch. Consequence: in the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury. Action: dealers will inspect the buckles and, if found to be inoperative, the entire buckle assembly would be replaced. for buckles found to be operative, dealer will replace only the upper buckle cover. the recall began on april 30, 2008. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. note: this campaign is an expansion of a previous recall (please see 05v558). Recall Date: 04/15/2008 | |
| 2006 GMC SAVANA Manufactured between: 04/01/2005 and 10/31/2005 Defect: on certain full-size passenger, cargo, or cutaway vans, the front and rear seat belt buckles will not latch or will not unlatch. Consequence: in the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury. Action: dealers will inspect the buckles and, if found to be inoperative, the entire buckle assembly would be replaced. for buckles found to be operative, dealer will replace only the upper buckle cover. the recall will be conducted in phases. the first phase mailing began during march 2006. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 12/19/2005 | |
| 2006 GMC SAVANA Manufactured between: 09/01/2005 and 09/07/2005 Defect: certain trucks and sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims.¿ these vehicles were shipped with tire and loading information labels listing an inacccurate vehicle capacity weight. Consequence: a misprinted label could lead to improper vehicle loading specifications or tire inflation which could result in a tire failure, increasing the risk of a crash. Action: owners will be provided with corrected labels and installation instructions. at the customer¿s option, a dealer can install the label for them. the recall began on march 31, 2006. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, hummer at 1-800-732-5493, pontiac at 1-800-620-7668, saturn at 1-800-972-8876, or isuzu at 1-800-255-6727. Recall Date: 12/07/2005 | |
| 2006 GMC SAVANA Manufactured between: 07/01/2005 and 08/31/2005 Defect: certain passenger vehicles may have been built with a power steering hose that is not to specification. under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid. Consequence: if this were to occur, power steering assist would be lost and increased steering effort would be required. on vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. if the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur. Action: dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. the recall will begin on october 14, 2005. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493. Recall Date: 10/05/2005 | |
| 2005 GMC SAVANA Manufactured between: 03/01/2004 and 06/30/2005 Defect: on certain full-size passenger, cargo, or cutaway vans, the front and rear seat belt buckles will not latch or will not unlatch. Consequence: in the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury. Action: dealers will inspect the buckles and, if found to be inoperative, the entire buckle assembly would be replaced. for buckles found to be operative, dealer will replace only the upper buckle cover. the recall will be conducted in phases. the first phase mailing began during march 2006. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 12/19/2005 | |
| 2005 GMC SAVANA Manufactured between: 05/01/2005 and 08/31/2005 Defect: certain conversion vans built on gmc/chevrolet chassis fail to comply with the requirements of federal motor vehicle safety standard no. 108, ¿lamps, reflective devices and associated equipment.¿ the housing lens of the center high mounted stop lamp does not allow enough light to emit from the lamp. Consequence: following vehicles may not be fully informed of vehicle braking. rear-end crashes and injury to occupants may occur. Action: quality coaches is working with audiovox to replace the center high-mounted brake lamp assembly. owners may contact quality coaches at 1-800-373-6357 or asa at 1-800-274-1886. Recall Date: 12/13/2005 | |
| 2005 GMC SAVANA Manufactured between: 03/01/2004 and 09/30/2004 Defect: certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. Consequence: if a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. Action: dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. Recall Date: 02/08/2005 | |
| 2004 GMC SAVANA Manufactured between: 03/01/2003 and 07/31/2004 Defect: on certain full-size passenger, cargo, or cutaway vans, the front and rear seat belt buckles will not latch or will not unlatch. Consequence: in the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury. Action: dealers will inspect the buckles and, if found to be inoperative, the entire buckle assembly would be replaced. for buckles found to be operative, dealer will replace only the upper buckle cover. the recall will be conducted in phases. the first phase mailing began during march 2006. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 12/19/2005 | |
| 2004 GMC SAVANA Manufactured between: 02/01/2004 and 07/31/2004 Defect: certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. Consequence: if a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. Action: dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. Recall Date: 02/08/2005 | |
| 2004 GMC SAVANA Manufactured between: 05/18/2004 and 05/25/2004 Defect: certain vans were built with a transmission shift cable assembly that may separate. if the cable assembly separates, the transmission shift lever position and the transmission indicator may no longer correlate. Consequence: if this were to occur, the vehicle could move in a direction not anticipated by the driver, which could result in a vehicle crash. Action: dealers will inspect the transmission shift cable assembly, and if necessary, replace it. the recall began on august 19, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 07/06/2004 | |
| 2004 GMC SAVANA Manufactured between: 03/01/2004 and 04/30/2004 Defect: certain vans fail to conform to the requirements of federal motor vehicle safety standard no. 209, ¿seat belt assemblies.¿ these vehicles may have been produced with seat belt buckle assemblies containing a latch with a brittle condition that may not withstand the force requirements of the standard. Consequence: the safety belt may not restrain the occupant as intended during a crash, which could result in injury to the occupant. Action: dealers will replace the safety belt buckle. the recall beagn may 7, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 04/19/2004 | |
| 2004 GMC SAVANA Manufactured between: 06/01/2003 and 06/30/2003 Defect: certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore. Consequence: consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture. Action: dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376. Recall Date: 02/04/2004 | |
| SAVANA 1500 RECALLS | Top |
| 2007 GMC SAVANA 1500 Manufactured between: 04/01/2007 and 05/31/2007 Defect: certain vans fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." when the brakes are applied, the stop lamps will illuminate. when the brake pedal is released, the stop lamps are no longer illuminated but the rear brakes may still be applied. the brake may release after a few seconds or after the next firm brake pedal application. Consequence: if the rear brakes are still applied after release of the brake pedal, the driver may notice a substantial drag when driving and may need to depress the gas pedal further than usual to continue vehicle movement. a vehicle driven with the brakes applied can cause overheating of the brakes, resulting in increased stopping distance which could result in a crash. Action: dealers will reprogram the abs system module. the recall began on september 28, 2007. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9643. Recall Date: 08/07/2007 | |
| SAVANA VAN RECALLS | Top |
| 2005 GMC SAVANA VAN Manufactured between: 05/11/2005 and 08/25/2005 Defect: certain conversion vans built on gmc/chevrolet chassis fail to comply with requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices and associated equipment." the housing lens of the center high mounted stop lamp does not allow enough light to emit from the lamp. Consequence: following vehicles may not be fully informed of vehicle braking. rear-end collisions and injury to occupants may occur. Action: santa fe is working with audiovox to replace the center high-mounted brake lamp assembly. owners may contact santa fe at 1-800-274-1886 or asa at 1-574-266-3172. Recall Date: 11/07/2005 | |
| SIERRA RECALLS | Top |
| 2006 GMC SIERRA Manufactured between: 04/01/2006 and 05/31/2006 Defect: certain sport utility vehicles and trucks fail to comply with the requirements of federal motor vehicle safety standard no. 110, ¿tire selection and rims." these vehicles have an incomplete tire rim designation on the certification/tire label located on the driver's door edge. in addition, the label may also be missing the tire load rating on the label. although this information is not required by the standard, if a tire of a lesser load rating is installed, the tire may not be able to sustain the loads encountered during use. Consequence: if a customer replaces a wheel and only relies on the rim size designation that is indicated on the label, a wheel that is of a different rim contour designation may be installed. it may be difficult or impossible to mount the tire on a wheel with the wrong contour. if the tire is mounted on the wheel with the wrong contour, the wheel and tire may not perform as intended, which could increase the risk of a crash. Action: a label that will correct the label originally installed will be mailed to consumers along with installation instructions. the customer will have the option for dealers to install the label. the recall begaon on november 7, 2006. owners should contact cadillac at 1-866-982-2239, chevrolet at 1-800-630-2438, and gmc trucks at 1-866-996-9463. Recall Date: 08/11/2006 | |
| 2006 GMC SIERRA Manufactured between: 05/01/2005 and 04/30/2005 Defect: on certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. Consequence: if the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. Recall Date: 08/03/2006 | |
| 2006 GMC SIERRA Manufactured between: 09/01/2005 and 09/07/2005 Defect: certain trucks and sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims.¿ these vehicles were shipped with tire and loading information labels listing an inacccurate vehicle capacity weight. Consequence: a misprinted label could lead to improper vehicle loading specifications or tire inflation which could result in a tire failure, increasing the risk of a crash. Action: owners will be provided with corrected labels and installation instructions. at the customer¿s option, a dealer can install the label for them. the recall began on march 31, 2006. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, hummer at 1-800-732-5493, pontiac at 1-800-620-7668, saturn at 1-800-972-8876, or isuzu at 1-800-255-6727. Recall Date: 12/07/2005 | |
| 2006 GMC SIERRA Manufactured between: 07/01/2005 and 08/31/2005 Defect: certain passenger vehicles may have been built with a power steering hose that is not to specification. under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid. Consequence: if this were to occur, power steering assist would be lost and increased steering effort would be required. on vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. if the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur. Action: dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. the recall will begin on october 14, 2005. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493. Recall Date: 10/05/2005 | |
| 2005 GMC SIERRA Manufactured between: 05/01/2005 and 05/31/2005 Defect: certain vehicles originally built with cloth seats that were equipped with an automatic air bag passenger sensing system and later reupholstered with aftermarket leather seat cover kits are involved. testing has indicated that the aftermarket leather seat covers can cause the passenger sensing system to malfunction. Consequence: if the passenger sensing system malfunctions, the front air bag on the passenger side may be disabled when it should be enabled, or enabled when it should be disabled. in either case, in the event of a crash that requires air bag deployment, a front passenger's level of injury may be increased. Action: because a replacement leather seat cover that is compatible with the passenger sensing system is not available, general motors (gm) will repurchase these vehicles in accordance with the terms stated in gm¿s letter to owners. the recall began on november 6, 2006. owners should contact gm at 1-877-477-1022 to begin the process of repurchasing their vehicle. Recall Date: 10/31/2006 | |
| 2005 GMC SIERRA Manufactured between: 03/01/2004 and 07/31/2005 Defect: on certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. Consequence: if the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. Recall Date: 08/03/2006 | |
| 2005 GMC SIERRA Manufactured between: 07/01/2005 and 08/31/2005 Defect: certain passenger vehicles may have been built with a power steering hose that is not to specification. under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid. Consequence: if this were to occur, power steering assist would be lost and increased steering effort would be required. on vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. if the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur. Action: dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. the recall will begin on october 14, 2005. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493. Recall Date: 10/05/2005 | |
| 2005 GMC SIERRA Manufactured between: 06/01/2004 and 07/31/2004 Defect: on certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle. Consequence: if the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash. Action: dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. on vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. the recall began on july 29, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 04/22/2005 | |
| 2005 GMC SIERRA Manufactured between: 02/24/2004 and 11/02/2004 Defect: on certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner¿s manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner¿s manual text. Consequence: a lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury. Action: dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493. Recall Date: 04/22/2005 | |
| 2005 GMC SIERRA Manufactured between: 01/01/2005 and 02/28/2005 Defect: certain sport utility vehicles equipped with an automatic transmission, fail to comply with the requirements of federal motor vehicle safety standard no. 102, "transmission shift lever sequence, starter interlock and transmission braking effect." under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. if the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in. Consequence: the vehicle may move in an unintended direction resulting in possible injury to others outside of the vehicle. Action: dealers will reprogram the instrument panel cluster free of charge. the recall began on february 14, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, and gmc at 1-866-996-9463. Recall Date: 02/14/2005 | |
| 2005 GMC SIERRA Manufactured between: 04/01/2004 and 09/30/2004 Defect: certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. Consequence: if a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. Action: dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. Recall Date: 02/08/2005 | |
| 2005 GMC SIERRA Manufactured between: 12/01/2004 and 01/31/2005 Defect: on certain trucks, the bolt that attaches the intermediate steering shaft to the steering gear may not meet specification. the bolt may fracture resulting in the loss of steering. Consequence: if this happens while the vehicle is moving, a crash could occur without prior warning. Action: dealers will replace the intermediate steering shaft bolt free of charge. the recall began on january 24, 2005. owners may contact gmc at 1-866-996-9463 and chevrolet at 1-800-630-2438. Recall Date: 01/21/2005 | |
| 2005 GMC SIERRA Manufactured between: 06/25/2004 and 07/26/2004 Defect: on certain sport utility vehicles and pickup trucks equipped with 5.3l (rpo l59) v8 engines, the engine fuel rail crossover tube retainer screws were not manufactured to specifications and may break. Consequence: if the tube retainer screw breaks, fuel could leak from the fuel rail crossover joint, the engine may stall and, if an ignition source were present, an engine compartment fire could occur. Action: dealers will inspect the fuel rail crossover tube and, if necessary, replace the retainer screws. owners were notified by telephone on july 30, 2004, with a followup owner letter began august 5, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. note: the gm bulletin lists the tahoe and yukon models because canadian vehicles are included in the bulletin. no u.s. tahoe or yukon vehicles are included in the u.s. campaign. Recall Date: 08/02/2004 | |
| 2004 GMC SIERRA Manufactured between: 03/01/2003 and 08/31/2004 Defect: on certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. Consequence: if the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. Recall Date: 08/03/2006 | |
| 2004 GMC SIERRA Manufactured between: 04/01/2003 and 07/31/2004 Defect: on certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle. Consequence: if the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash. Action: dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. on vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. the recall began on july 29, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 04/22/2005 | |
| 2004 GMC SIERRA Manufactured between: 04/08/2003 and 08/04/2004 Defect: on certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner¿s manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner¿s manual text. Consequence: a lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury. Action: dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493. Recall Date: 04/22/2005 | |
| 2004 GMC SIERRA Manufactured between: 02/01/2004 and 08/31/2004 Defect: certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. Consequence: if a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. Action: dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. Recall Date: 02/08/2005 | |
| 2004 GMC SIERRA Manufactured between: 08/01/2003 and 03/31/2004 Defect: certain extended and regular cab pickup trucks and cargo vans converted to compressed natural gas (cng) fail to conform to the requirements of federal motor vehicle safety standard no. 225, 'child restraint anchorage systems.' these vehicles have one seating position, the center rear seat, equipped with child restraint lower anchorages. Consequence: the standard requires child seat lower anchorages in two seating positions for vehicles with three rear seating positions. the standard cab and cargo van vehicles, which only have front seating positions, have an air bag off switch to disable the front passenger air bag and do not have child restraint lower anchorages in the passenger seat. the standard requires passenger seat child seat lower anchorages in vehicles with an air bag off switch. however, the standard does not require vehicles with only front seating positions to have lower anchorage provisions if the vehicle is not equipped with an air bag off switch. Action: to bring the standard cab and cargo van vehicles into compliance, dealers will inject epoxy into the air bag off switch to prevent air bag activation, relocate the switch behind the instrument panel and then install a cover over the resulting opening. the sun visor label and owner's manual will also be changed. the correction for the extended cab vehicle will consist of changing the front passenger seat to a seat that has child restraint lower anchorages. the recall began on september 9, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 05/11/2004 | |
| 2004 GMC SIERRA Manufactured between: 03/01/2003 and 11/30/2003 Defect: on certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. if both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper. Consequence: anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. on vehicles that have had the bumper removed, the tailgate may drop even lower. additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture. Action: dealers will replace the cables. interim owner notification began on april 7, 20004. the recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number. Recall Date: 03/17/2004 | |
| 2004 GMC SIERRA Manufactured between: 05/01/2003 and 06/30/2003 Defect: certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore. Consequence: consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture. Action: dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376. Recall Date: 02/04/2004 | |
| SIERRA DENALI RECALLS | Top |
| 2005 GMC SIERRA DENALI Manufactured between: 04/01/2004 and 02/28/2005 Defect: certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage systems" the requirements for location and instructions for properly attaching child restraints. the owner manual in these vehicles indicate the incorrect seat locations with upper and lower tether anchors, and provide incorrect installation instructions for the top tether anchorage. Consequence: improper use of child restraint anchorage could result in personal injury to the seat occupant. Action: dealers will mail an owner's manual update that describes the location and proper use of the tether anchors. the recall began on april 15, 2005. owners may contact gmc at 1-866-996-9463. Recall Date: 03/31/2005 | |
| SONOMA RECALLS | Top |
| 2004 GMC SONOMA Manufactured between: 04/01/2003 and 02/29/2004 Defect: certain pickup trucks and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 208, ¿occupant crash protection.¿ Consequence: some of these vehicles include incorrect statements on one of the air bag warning labels. Action: owners will be provided with correct labels and installation instructions. owner notification began on june 4, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 03/18/2004 | |
| T-SERIES RECALLS | Top |
| 2007 GMC T-SERIES Manufactured between: 04/01/2006 and 04/30/2007 Defect: on certain medium duty conventional and tilt cab trucks equipped with 7.8l diesel engines and air brakes, the air compressor may not build enough air pressure to support the air brake system. Consequence: if this condition were to occur while the vehicle was stationary (brakes applied) the air brakes would remain applied and prevent the vehicle from moving. if this condition were to occur while the vehicle was in motion, the dual system air pressure gauges would register the drop in pressure. if the pressure continued to drop, the low air pressure warning buzzer and warning lamp would activate as designed, warning the driver to move the vehicle to a safety location. if the driver ignores these warnings and continues to drive the vehicle, and if there was a continued loss of pressure, the rear spring parking brakes would automatically apply, preventing the truck from being driven. Action: dealers will replace the air compressor head. the recall began on may 23, 2007. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or isuzu at 1-800-255-6727. Recall Date: 05/02/2007 | |
| 2006 GMC T-SERIES Manufactured between: 07/01/2005 and 04/30/2006 Defect: certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 121, ¿air brake systems." an internal control and check valve within the air brake application valve assembly was configured improperly, preventing air from flowing through the brake system as designed. in the event of an emergency stop, the vehicle's stopping distance would be increased. Consequence: if stopping distance was limited, a vehicle crash could result. Action: dealers will replace the air brake application valve assembly on c-series or reroute the air brake lines on t-series free of charge. the recall began on september 20, 2006. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463 and isuzu at 1-800-255-6727. Recall Date: 08/16/2006 | |
| 2006 GMC T-SERIES Manufactured between: 04/01/2006 and 06/30/2006 Defect: certain medium duty trucks equipped sr-7 bendix brake valves, the check valve inside the valve cavity may not properly set, causing internal air leakage. if the check valve does not properly seat, the resulting leakage can cause a delay in the application of the spring brakes to park the vehicle after operator pulls the dash valve button. Consequence: the delayed parking brake application can occur without warning, leading to unintended vehicle rollaway increasing the risk of a crash. Action: dealers will inspect the valves and replace it free of charge. the recall began on july 31, 2006. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or isuzu at 1-800-255-6727. Recall Date: 07/13/2006 | |
| TOPKICK RECALLS | Top |
| 2008 GMC TOPKICK Manufactured between: 05/01/2007 and 05/31/2008 Defect: gm is recalling 319 my 2008 c-series chevrolet kodiak and gmc topkick trucks equipped with caterpillar c9 diesel engines. the fuel pump outlet check plug may be cracked which could cause fuel to spray and leak. Consequence: fuel leakage, in the presence of an ignition source, could result in a fire. Action: general motors is working with caterpillar (please see 08e042). caterpillar will replace the fuel pump plug free of charge. owners may contact caterpillar at 1-800-447-4986, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463 or the gm owner center at mygmlink, http://www.gm.com/recalls. Recall Date: 08/06/2008 | |
| 2007 GMC TOPKICK Manufactured between: 06/01/2006 and 07/31/2007 Defect: on certain medium duty trucks equipped with zf model 8018 steering gears, the steering gear may have been produced incorrectly. a steering gear with this condition may produce the feeling of hitting a curb and a cracking or pinging sound when the steering wheel is turned. Consequence: the steering wheel position may be off-center and increased effort may be required when turning, increasing the risk of a crash. Action: dealers will inspect for certain date codes and verify the mileage on steering gears and replace gears as necessary. the recall began on october 25, 2007. owners may contact chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or isuzu at 1-800-255-6727. Recall Date: 10/04/2007 | |
| 2007 GMC TOPKICK Manufactured between: 04/01/2006 and 07/31/2007 Defect: on certain straight towing or non-towing trucks equipped with bendix air brakes, the air brake park control valve may develop either an internal air leak or an air restriction. the park brake may not release or may release only partially. Consequence: if the vehicle is on an uneven surface, the park brake may not hold the vehicle and could result in unintended vehicle movement and a vehicle crash. this condition does not affect normal service braking. Action: dealers will inspect and replace the external check valve on the air brake park control valve if the inspection determines the external check valve is damaged, the air brake park control valve will be replaced and may require the replacement of an internal check valve in the air brake park control valve. remedy will be free of charge. the recall began on october 22, 2007. owners may contact gm at 1-800-862-4389 or isuzu at 1-800-255-6727. Recall Date: 08/28/2007 | |
| 2007 GMC TOPKICK Manufactured between: 04/01/2006 and 04/30/2007 Defect: on certain medium duty conventional and tilt cab trucks equipped with 7.8l diesel engines and air brakes, the air compressor may not build enough air pressure to support the air brake system. Consequence: if this condition were to occur while the vehicle was stationary (brakes applied) the air brakes would remain applied and prevent the vehicle from moving. if this condition were to occur while the vehicle was in motion, the dual system air pressure gauges would register the drop in pressure. if the pressure continued to drop, the low air pressure warning buzzer and warning lamp would activate as designed, warning the driver to move the vehicle to a safety location. if the driver ignores these warnings and continues to drive the vehicle, and if there was a continued loss of pressure, the rear spring parking brakes would automatically apply, preventing the truck from being driven. Action: dealers will replace the air compressor head. the recall began on may 23, 2007. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or isuzu at 1-800-255-6727. Recall Date: 05/02/2007 | |
| 2007 GMC TOPKICK Manufactured between: 11/29/2005 and 03/01/2006 Defect: on certain trucks, the rear drive axle housing was manufactured with steel below the specified thickness and, as a result, it could develop a crack. Consequence: if a crack develops and is not detected and repaired, the outboard end of the housing could eventually separate, allowing the hub, axle shaft, or wheel and brake assembly to separate from the vehicle increasing the risk of a crash. Action: dealers will inspect and replace the axle free of charge. the recall began on april 12, 2007. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 04/10/2007 | |
| 2006 GMC TOPKICK Manufactured between: 07/01/2005 and 06/30/2006 Defect: on certain medium duty trucks equipped with zf model 8018 steering gears, the steering gear may have been produced incorrectly. a steering gear with this condition may produce the feeling of hitting a curb and a cracking or pinging sound when the steering wheel is turned. Consequence: the steering wheel position may be off-center and increased effort may be required when turning, increasing the risk of a crash. Action: dealers will inspect for certain date codes and verify the mileage on steering gears and replace gears as necessary. the recall began on october 25, 2007. owners may contact chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or isuzu at 1-800-255-6727. Recall Date: 10/04/2007 | |
| 2006 GMC TOPKICK Manufactured between: 04/01/2005 and 06/30/2006 Defect: on certain straight towing or non-towing trucks equipped with bendix air brakes, the air brake park control valve may develop either an internal air leak or an air restriction. the park brake may not release or may release only partially. Consequence: if the vehicle is on an uneven surface, the park brake may not hold the vehicle and could result in unintended vehicle movement and a vehicle crash. this condition does not affect normal service braking. Action: dealers will inspect and replace the external check valve on the air brake park control valve if the inspection determines the external check valve is damaged, the air brake park control valve will be replaced and may require the replacement of an internal check valve in the air brake park control valve. remedy will be free of charge. the recall began on october 22, 2007. owners may contact gm at 1-800-862-4389 or isuzu at 1-800-255-6727. Recall Date: 08/28/2007 | |
| 2006 GMC TOPKICK Manufactured between: 07/01/2005 and 04/30/2006 Defect: certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 121, ¿air brake systems." an internal control and check valve within the air brake application valve assembly was configured improperly, preventing air from flowing through the brake system as designed. in the event of an emergency stop, the vehicle's stopping distance would be increased. Consequence: if stopping distance was limited, a vehicle crash could result. Action: dealers will replace the air brake application valve assembly on c-series or reroute the air brake lines on t-series free of charge. the recall began on september 20, 2006. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463 and isuzu at 1-800-255-6727. Recall Date: 08/16/2006 | |
| 2006 GMC TOPKICK Manufactured between: 04/01/2006 and 06/30/2006 Defect: certain medium duty trucks equipped sr-7 bendix brake valves, the check valve inside the valve cavity may not properly set, causing internal air leakage. if the check valve does not properly seat, the resulting leakage can cause a delay in the application of the spring brakes to park the vehicle after operator pulls the dash valve button. Consequence: the delayed parking brake application can occur without warning, leading to unintended vehicle rollaway increasing the risk of a crash. Action: dealers will inspect the valves and replace it free of charge. the recall began on july 31, 2006. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or isuzu at 1-800-255-6727. Recall Date: 07/13/2006 | |
| 2005 GMC TOPKICK Manufactured between: 06/01/2004 and 07/31/2005 Defect: on certain medium duty trucks equipped with zf model 8018 steering gears, the steering gear may have been produced incorrectly. a steering gear with this condition may produce the feeling of hitting a curb and a cracking or pinging sound when the steering wheel is turned. Consequence: the steering wheel position may be off-center and increased effort may be required when turning, increasing the risk of a crash. Action: dealers will inspect for certain date codes and verify the mileage on steering gears and replace gears as necessary. the recall began on october 25, 2007. owners may contact chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or isuzu at 1-800-255-6727. Recall Date: 10/04/2007 | |
| 2005 GMC TOPKICK Manufactured between: 05/01/2004 and 09/30/2004 Defect: certain 2003-2005 model year 4500/5500 series chevrolet kodiak, school bus chassis, and gmc topkick vehicles; and 2003-2004 model year gmc school bus chassis vehicles equipped with an 8.1l engine and hydromax brake system. the power steering hose may come into contact with a portion of the intermediate steering shaft. a hole could be worn in the hose and a loss of hydraulic fluid would occur. Consequence: if there is sufficient amount of fluid loss, the driver will hear a noise from the power steering pump, the brake warning light and warning tone will activate. increased effort may be required for steering and braking, increasing the risk of a crash. Action: gm will notify its customers and dealers will reroute the power steering hose. if the steel braiding of the hose is exposed, dealers are to replace the hose free of charge. the recall began on july 12, 2005. owners may contact chevrolet at 800-630-2438 or gmc at 866-996-9463. Recall Date: 06/16/2005 | |
| 2005 GMC TOPKICK Manufactured between: 04/01/2004 and 08/31/2004 Defect: certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. Consequence: if a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. Action: dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. Recall Date: 02/08/2005 | |
| 2004 GMC TOPKICK Manufactured between: 07/01/2003 and 06/30/2004 Defect: on certain medium duty trucks equipped with zf model 8018 steering gears, the steering gear may have been produced incorrectly. a steering gear with this condition may produce the feeling of hitting a curb and a cracking or pinging sound when the steering wheel is turned. Consequence: the steering wheel position may be off-center and increased effort may be required when turning, increasing the risk of a crash. Action: dealers will inspect for certain date codes and verify the mileage on steering gears and replace gears as necessary. the recall began on october 25, 2007. owners may contact chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or isuzu at 1-800-255-6727. Recall Date: 10/04/2007 | |
| 2004 GMC TOPKICK Manufactured between: 05/01/2003 and 06/30/2004 Defect: certain 2003-2005 model year 4500/5500 series chevrolet kodiak, school bus chassis, and gmc topkick vehicles; and 2003-2004 model year gmc school bus chassis vehicles equipped with an 8.1l engine and hydromax brake system. the power steering hose may come into contact with a portion of the intermediate steering shaft. a hole could be worn in the hose and a loss of hydraulic fluid would occur. Consequence: if there is sufficient amount of fluid loss, the driver will hear a noise from the power steering pump, the brake warning light and warning tone will activate. increased effort may be required for steering and braking, increasing the risk of a crash. Action: gm will notify its customers and dealers will reroute the power steering hose. if the steel braiding of the hose is exposed, dealers are to replace the hose free of charge. the recall began on july 12, 2005. owners may contact chevrolet at 800-630-2438 or gmc at 866-996-9463. Recall Date: 06/16/2005 | |
| 2004 GMC TOPKICK Manufactured between: 02/01/2004 and 05/31/2004 Defect: certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. Consequence: if a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. Action: dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. Recall Date: 02/08/2005 | |
| 2004 GMC TOPKICK Manufactured between: 03/01/2003 and 11/30/2003 Defect: on certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. if both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper. Consequence: anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. on vehicles that have had the bumper removed, the tailgate may drop even lower. additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture. Action: dealers will replace the cables. interim owner notification began on april 7, 20004. the recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number. Recall Date: 03/17/2004 | |
| 2004 GMC TOPKICK Manufactured between: 01/01/2004 and 02/29/2004 Defect: on certain trucks, the switch retainer holding the brake booster push rod and the brake pedal together could be missing. Consequence: this could cause the push rod and pedal to separate, resulting in a loss of foundation brakes and increasing the risk of a crash. Action: dealers will inspect and install a new retainer if missing. owner notification began march 5, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact gmcict at 1-800-862-4389. Recall Date: 03/10/2004 | |
| TOPKICK 6500 RECALLS | Top |
| 2006 GMC TOPKICK 6500 Manufactured between: 04/01/2005 and 06/30/2006 Defect: on certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. Consequence: if the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. Recall Date: 08/03/2006 | |
| TOPKICK 8500 RECALLS | Top |
| 2006 GMC TOPKICK 8500 Manufactured between: 07/01/2005 and 04/30/2006 Defect: certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 121, ¿air brake systems." an internal control and check valve within the air brake application valve assembly was configured improperly, preventing air from flowing through the brake system as designed. in the event of an emergency stop, the vehicle's stopping distance would be increased. Consequence: if stopping distance was limited, a vehicle crash could result. Action: dealers will replace the air brake application valve assembly on c-series or reroute the air brake lines on t-series free of charge. the recall began on september 20, 2006. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463 and isuzu at 1-800-255-6727. Recall Date: 08/16/2006 | |
| 2006 GMC TOPKICK 8500 Manufactured between: 04/01/2006 and 06/30/2006 Defect: certain medium duty trucks equipped sr-7 bendix brake valves, the check valve inside the valve cavity may not properly set, causing internal air leakage. if the check valve does not properly seat, the resulting leakage can cause a delay in the application of the spring brakes to park the vehicle after operator pulls the dash valve button. Consequence: the delayed parking brake application can occur without warning, leading to unintended vehicle rollaway increasing the risk of a crash. Action: dealers will inspect the valves and replace it free of charge. the recall began on july 31, 2006. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or isuzu at 1-800-255-6727. Recall Date: 07/13/2006 | |
| W3500 RECALLS | Top |
| 2007 GMC W3500 Manufactured between: 06/20/2006 and 03/07/2007 Defect: isuzu is recalling 16,859 my 2006-2007 isuzu npr, nqr, nrr, gmc w3500, w4500, w5500 and chevrolet w3500, w4500, w5500 trucks equipped with diesel engines. diesel fuel may seep or leak from the fuel pipe at the upper or lower fuel port on the diesel fuel supply pump. Consequence: fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will inspect the vehicles and if no seepage or leakage is detected, the fuel pipe fittings will be tightened. if seepage or leakage is detected, the fuel supply pump will be replaced with a new one. the recall will begin on june 30, 2008. owners may contact isuzu at 1-800-255-6727, gmc at 1-866-996-9463, or chevrolet at 1-800-630-2438.. Recall Date: 06/05/2008 | |
| 2006 GMC W3500 Manufactured between: 06/20/2006 and 03/07/2007 Defect: isuzu is recalling 16,859 my 2006-2007 isuzu npr, nqr, nrr, gmc w3500, w4500, w5500 and chevrolet w3500, w4500, w5500 trucks equipped with diesel engines. diesel fuel may seep or leak from the fuel pipe at the upper or lower fuel port on the diesel fuel supply pump. Consequence: fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will inspect the vehicles and if no seepage or leakage is detected, the fuel pipe fittings will be tightened. if seepage or leakage is detected, the fuel supply pump will be replaced with a new one. the recall will begin on june 30, 2008. owners may contact isuzu at 1-800-255-6727, gmc at 1-866-996-9463, or chevrolet at 1-800-630-2438.. Recall Date: 06/05/2008 | |
| 2004 GMC W3500 Manufactured between: 07/01/2002 and 07/31/2004 Defect: on certain trucks equipped with rpo ik9, due to insufficient durability and testing, the fuel switching manifold solenoids lack water or salt intrusion resistance, which can lead to failure of one or more solenoids. fuel switching manifold solenoid failure will cause incorrect fuel delivery resulting in fuel overflow from the fuel filler neck. Consequence: overflow fuel may result in high amount of diesel fuel leakage. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the solenoid valve assembly with an improved assembly including additional detection circuit and enhanced water resistance free of charge. the recall began on october 27, 2005. owners may contact isuzu at 1-800-255-6727. Recall Date: 04/20/2005 | |
| W4500 RECALLS | Top |
| 2007 GMC W4500 Manufactured between: 06/20/2006 and 03/07/2007 Defect: isuzu is recalling 16,859 my 2006-2007 isuzu npr, nqr, nrr, gmc w3500, w4500, w5500 and chevrolet w3500, w4500, w5500 trucks equipped with diesel engines. diesel fuel may seep or leak from the fuel pipe at the upper or lower fuel port on the diesel fuel supply pump. Consequence: fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will inspect the vehicles and if no seepage or leakage is detected, the fuel pipe fittings will be tightened. if seepage or leakage is detected, the fuel supply pump will be replaced with a new one. the recall will begin on june 30, 2008. owners may contact isuzu at 1-800-255-6727, gmc at 1-866-996-9463, or chevrolet at 1-800-630-2438.. Recall Date: 06/05/2008 | |
| 2006 GMC W4500 Manufactured between: 06/20/2006 and 03/07/2007 Defect: isuzu is recalling 16,859 my 2006-2007 isuzu npr, nqr, nrr, gmc w3500, w4500, w5500 and chevrolet w3500, w4500, w5500 trucks equipped with diesel engines. diesel fuel may seep or leak from the fuel pipe at the upper or lower fuel port on the diesel fuel supply pump. Consequence: fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will inspect the vehicles and if no seepage or leakage is detected, the fuel pipe fittings will be tightened. if seepage or leakage is detected, the fuel supply pump will be replaced with a new one. the recall will begin on june 30, 2008. owners may contact isuzu at 1-800-255-6727, gmc at 1-866-996-9463, or chevrolet at 1-800-630-2438.. Recall Date: 06/05/2008 | |
| 2004 GMC W4500 Manufactured between: 07/01/2002 and 07/31/2004 Defect: on certain trucks equipped with rpo ik9, due to insufficient durability and testing, the fuel switching manifold solenoids lack water or salt intrusion resistance, which can lead to failure of one or more solenoids. fuel switching manifold solenoid failure will cause incorrect fuel delivery resulting in fuel overflow from the fuel filler neck. Consequence: overflow fuel may result in high amount of diesel fuel leakage. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the solenoid valve assembly with an improved assembly including additional detection circuit and enhanced water resistance free of charge. the recall began on october 27, 2005. owners may contact isuzu at 1-800-255-6727. Recall Date: 04/20/2005 | |
| W5500 RECALLS | Top |
| 2007 GMC W5500 Manufactured between: 06/20/2006 and 03/07/2007 Defect: isuzu is recalling 16,859 my 2006-2007 isuzu npr, nqr, nrr, gmc w3500, w4500, w5500 and chevrolet w3500, w4500, w5500 trucks equipped with diesel engines. diesel fuel may seep or leak from the fuel pipe at the upper or lower fuel port on the diesel fuel supply pump. Consequence: fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will inspect the vehicles and if no seepage or leakage is detected, the fuel pipe fittings will be tightened. if seepage or leakage is detected, the fuel supply pump will be replaced with a new one. the recall will begin on june 30, 2008. owners may contact isuzu at 1-800-255-6727, gmc at 1-866-996-9463, or chevrolet at 1-800-630-2438.. Recall Date: 06/05/2008 | |
| 2006 GMC W5500 Manufactured between: 06/20/2006 and 03/07/2007 Defect: isuzu is recalling 16,859 my 2006-2007 isuzu npr, nqr, nrr, gmc w3500, w4500, w5500 and chevrolet w3500, w4500, w5500 trucks equipped with diesel engines. diesel fuel may seep or leak from the fuel pipe at the upper or lower fuel port on the diesel fuel supply pump. Consequence: fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will inspect the vehicles and if no seepage or leakage is detected, the fuel pipe fittings will be tightened. if seepage or leakage is detected, the fuel supply pump will be replaced with a new one. the recall will begin on june 30, 2008. owners may contact isuzu at 1-800-255-6727, gmc at 1-866-996-9463, or chevrolet at 1-800-630-2438.. Recall Date: 06/05/2008 | |
| 2004 GMC W5500 Manufactured between: 07/01/2002 and 07/31/2004 Defect: on certain trucks equipped with rpo ik9, due to insufficient durability and testing, the fuel switching manifold solenoids lack water or salt intrusion resistance, which can lead to failure of one or more solenoids. fuel switching manifold solenoid failure will cause incorrect fuel delivery resulting in fuel overflow from the fuel filler neck. Consequence: overflow fuel may result in high amount of diesel fuel leakage. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the solenoid valve assembly with an improved assembly including additional detection circuit and enhanced water resistance free of charge. the recall began on october 27, 2005. owners may contact isuzu at 1-800-255-6727. Recall Date: 04/20/2005 | |
| YUKON RECALLS | Top |
| 2006 GMC YUKON Manufactured between: 09/01/2005 and 09/07/2005 Defect: certain trucks and sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims.¿ these vehicles were shipped with tire and loading information labels listing an inacccurate vehicle capacity weight. Consequence: a misprinted label could lead to improper vehicle loading specifications or tire inflation which could result in a tire failure, increasing the risk of a crash. Action: owners will be provided with corrected labels and installation instructions. at the customer¿s option, a dealer can install the label for them. the recall began on march 31, 2006. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, hummer at 1-800-732-5493, pontiac at 1-800-620-7668, saturn at 1-800-972-8876, or isuzu at 1-800-255-6727. Recall Date: 12/07/2005 | |
| 2006 GMC YUKON Manufactured between: 07/01/2005 and 08/31/2005 Defect: certain passenger vehicles may have been built with a power steering hose that is not to specification. under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid. Consequence: if this were to occur, power steering assist would be lost and increased steering effort would be required. on vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. if the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur. Action: dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. the recall will begin on october 14, 2005. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, buick at 1-866-608-8080, cadillac at 1-866-982-2339, isuzu at 1-800-255-6727, or hummer at 1-800-732-5493. Recall Date: 10/05/2005 | |
| 2005 GMC YUKON Manufactured between: 02/24/2004 and 11/02/2004 Defect: on certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner¿s manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner¿s manual text. Consequence: a lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury. Action: dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493. Recall Date: 04/22/2005 | |
| 2005 GMC YUKON Manufactured between: 02/01/2004 and 03/10/2005 Defect: on certain sport utility vehicles, the brake pedal pushrod retainer may be missing. if the retainer is missing, the brake booster pushrod could disengage from the brake pedal. Consequence: this could result in a loss of brakes which could result in a crash. Action: dealers will inspect the vehicles for the brake pedal pushrod retainer and install one if it is missing free of charge. the manufacturer began contacting owners by telephone on march 10, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 03/18/2005 | |
| 2005 GMC YUKON Manufactured between: 01/01/2005 and 02/28/2005 Defect: certain sport utility vehicles equipped with an automatic transmission, fail to comply with the requirements of federal motor vehicle safety standard no. 102, "transmission shift lever sequence, starter interlock and transmission braking effect." under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. if the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in. Consequence: the vehicle may move in an unintended direction resulting in possible injury to others outside of the vehicle. Action: dealers will reprogram the instrument panel cluster free of charge. the recall began on february 14, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, and gmc at 1-866-996-9463. Recall Date: 02/14/2005 | |
| 2004 GMC YUKON Manufactured between: 04/08/2003 and 08/04/2004 Defect: on certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner¿s manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner¿s manual text. Consequence: a lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury. Action: dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493. Recall Date: 04/22/2005 | |
| 2004 GMC YUKON Manufactured between: 05/01/2003 and 06/30/2003 Defect: certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore. Consequence: consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture. Action: dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376. Recall Date: 02/04/2004 | |
| YUKON XL RECALLS | Top |
| 2006 GMC YUKON XL Manufactured between: 07/31/2005 and 01/31/2006 Defect: on certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. Consequence: if the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. Recall Date: 08/03/2006 | |
| 2006 GMC YUKON XL Manufactured between: 09/01/2005 and 09/07/2005 Defect: certain trucks and sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims.¿ these vehicles were shipped with tire and loading information labels listing an inacccurate vehicle capacity weight. Consequence: a misprinted label could lead to improper vehicle loading specifications or tire inflation which could result in a tire failure, increasing the risk of a crash. Action: owners will be provided with corrected labels and installation instructions. at the customer¿s option, a dealer can install the label for them. the recall began on march 31, 2006. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, hummer at 1-800-732-5493, pontiac at 1-800-620-7668, saturn at 1-800-972-8876, or isuzu at 1-800-255-6727. Recall Date: 12/07/2005 | |
| 2005 GMC YUKON XL Manufactured between: 06/01/2004 and 06/30/2005 Defect: on certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. Consequence: if the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. Recall Date: 08/03/2006 | |
| 2005 GMC YUKON XL Manufactured between: 02/01/2004 and 03/10/2005 Defect: on certain sport utility vehicles, the brake pedal pushrod retainer may be missing. if the retainer is missing, the brake booster pushrod could disengage from the brake pedal. Consequence: this could result in a loss of brakes which could result in a crash. Action: dealers will inspect the vehicles for the brake pedal pushrod retainer and install one if it is missing free of charge. the manufacturer began contacting owners by telephone on march 10, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. Recall Date: 03/18/2005 | |
| 2005 GMC YUKON XL Manufactured between: 01/01/2005 and 02/28/2005 Defect: certain sport utility vehicles equipped with an automatic transmission, fail to comply with the requirements of federal motor vehicle safety standard no. 102, "transmission shift lever sequence, starter interlock and transmission braking effect." under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. if the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in. Consequence: the vehicle may move in an unintended direction resulting in possible injury to others outside of the vehicle. Action: dealers will reprogram the instrument panel cluster free of charge. the recall began on february 14, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, and gmc at 1-866-996-9463. Recall Date: 02/14/2005 | |
| 2005 GMC YUKON XL Manufactured between: 04/01/2004 and 09/30/2004 Defect: certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. Consequence: if a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. Action: dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. Recall Date: 02/08/2005 | |
| 2005 GMC YUKON XL Manufactured between: 06/25/2004 and 07/26/2004 Defect: on certain sport utility vehicles and pickup trucks equipped with 5.3l (rpo l59) v8 engines, the engine fuel rail crossover tube retainer screws were not manufactured to specifications and may break. Consequence: if the tube retainer screw breaks, fuel could leak from the fuel rail crossover joint, the engine may stall and, if an ignition source were present, an engine compartment fire could occur. Action: dealers will inspect the fuel rail crossover tube and, if necessary, replace the retainer screws. owners were notified by telephone on july 30, 2004, with a followup owner letter began august 5, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463. note: the gm bulletin lists the tahoe and yukon models because canadian vehicles are included in the bulletin. no u.s. tahoe or yukon vehicles are included in the u.s. campaign. Recall Date: 08/02/2004 | |
| 2004 GMC YUKON XL Manufactured between: 03/31/2003 and 06/30/2004 Defect: on certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. Consequence: if the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. Recall Date: 08/03/2006 | |
| 2004 GMC YUKON XL Manufactured between: 02/01/2004 and 08/31/2004 Defect: certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. Consequence: if a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. Action: dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. Recall Date: 02/08/2005 | |
| 2004 GMC YUKON XL Manufactured between: 05/01/2003 and 06/30/2003 Defect: certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore. Consequence: consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture. Action: dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376. Recall Date: 02/04/2004 | |
Recall reports are furnished as a courtesy to our customers and are not represented as complete, definitive or authoritative. |
Copyright ©2006 Ikon Auto |
|
Site Management: Fabien Vegas Corporation
|