|
|
|
|
|
|
| |
Automobile Manufacturer Recall Data - Dodge Recalls 
Posted: 05-07-2008 | |
| AVENGER CALIBER CARAVAN CHARGER DAKOTA DURANGO GRAND CARAVAN MAGNUM NITRO NITRO 4X2 RAM RAM 1500 RAM 2500 RAM 3500 SPRINTER SPRINTER 2500 SPRINTER 3500 STRATUS | |
| AVENGER RECALLS | Top |
| 2008 DODGE AVENGER Manufactured between: 03/07/2006 and 01/24/2008 Defect: chrysler is recalling 180,963 my 2007-2008 sebring and dodge avenger vehicles equipped with a standard tire pressure monitoring system (tpms). unused electrical connectors for the tpms may become corroded and could short circuit, which can cause a variety of conditions including engine no-start, dead battery, an inoperative cruise control or remote start system, and/or engine stalling. Consequence: engine stalling could cause a crash without warning. Action: dealers will seal the wires for the tpms free of charge. the recall began on april 15, 2008. owners may contact chrysler at 1-800-853-1403. Recall Date: 04/02/2008 | |
| 2008 DODGE AVENGER Manufactured between: 03/09/2006 and 07/27/2007 Defect: on certain vehicles equipped with 2.4 liter engines, the engine coolant may be drawn into the left radiator cooling fan motor connector. Consequence: this can cause an electrical short circuit and result in an engine compartment fire. Action: dealers will inspect the connector for contamination or damage, install a wiring harness overlay, and replace the fan motor free or charge. the recall began on november 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/10/2007 | |
| 2008 DODGE AVENGER Manufactured between: 04/25/2007 and 07/03/2007 Defect: on certain vehicles with all wheel drive, the fuel tank straps were improperly manufactured and could separate. this can cause the fuel tank to loosen and leak fuel. Consequence: fuel leakage in the presence of an ignition source can result in an underbody fire. Action: dealers will replace the fuel tank retention straps free of charge. the recall is expected to begin during october 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/13/2007 | |
| 2008 DODGE AVENGER Manufactured between: 10/11/2006 and 07/13/2007 Defect: on certain vehicles, the front door latch cable may become partially unseated from the interior release handle housing possibly causing the latch to stick in the unlatched position or the lock function to become inoperative. Consequence: driving a vehicle with an unlatched door can result in an unbelted front seat occupant falling out of the vehicle or being ejected in a crash, causing increased risk of injury. Action: dealers will add a secondary retention feature to both front doors. this action will supersede and expand a previous safety recall (please see 07v-104). the recall began on october 29, 2007. owners may contact chrysler at 1-800-853-1403. Recall Date: 09/12/2007 | |
| 2008 DODGE AVENGER Manufactured between: 04/17/2007 and 04/19/2007 Defect: on certain passenger vehicles, the front seat track position sensors utilized for the air bag system may not function properly. Consequence: this could increase the risk of injury to front seat occupants during certain crash conditions. Action: dealers will inspect the front seat track position sensors and replace them free of charge. the recallbegan on june 18, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 06/13/2007 | |
| 2008 DODGE AVENGER Manufactured between: 08/08/2006 and 02/22/2007 Defect: on certain passenger vehicles, the front door latch cable may become partially unseated from the interior release handle housing causing the door latch to stick in the open position and not be secured to the striker. Consequence: during certain crash conditions, the possibility of a door opening could cause an unbelted passenger to be ejected, increasing the risk of injuries. Action: this action is superseded (please see 07-v414.) dealers will add free of charge a secondary feature to both front doors to prevent the door latch cable ferrule from becoming unseated at the interior front door release handle housing. the recall began on april 30, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/15/2007 | |
| 2007 DODGE AVENGER Manufactured between: 03/07/2006 and 01/24/2008 Defect: chrysler is recalling 180,963 my 2007-2008 sebring and dodge avenger vehicles equipped with a standard tire pressure monitoring system (tpms). unused electrical connectors for the tpms may become corroded and could short circuit, which can cause a variety of conditions including engine no-start, dead battery, an inoperative cruise control or remote start system, and/or engine stalling. Consequence: engine stalling could cause a crash without warning. Action: dealers will seal the wires for the tpms free of charge. the recall began on april 15, 2008. owners may contact chrysler at 1-800-853-1403. Recall Date: 04/02/2008 | |
| 2007 DODGE AVENGER Manufactured between: 03/09/2006 and 07/27/2007 Defect: on certain vehicles equipped with 2.4 liter engines, the engine coolant may be drawn into the left radiator cooling fan motor connector. Consequence: this can cause an electrical short circuit and result in an engine compartment fire. Action: dealers will inspect the connector for contamination or damage, install a wiring harness overlay, and replace the fan motor free or charge. the recall began on november 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/10/2007 | |
| 2007 DODGE AVENGER Manufactured between: 10/11/2006 and 07/13/2007 Defect: on certain vehicles, the front door latch cable may become partially unseated from the interior release handle housing possibly causing the latch to stick in the unlatched position or the lock function to become inoperative. Consequence: driving a vehicle with an unlatched door can result in an unbelted front seat occupant falling out of the vehicle or being ejected in a crash, causing increased risk of injury. Action: dealers will add a secondary retention feature to both front doors. this action will supersede and expand a previous safety recall (please see 07v-104). the recall began on october 29, 2007. owners may contact chrysler at 1-800-853-1403. Recall Date: 09/12/2007 | |
| 2007 DODGE AVENGER Manufactured between: 08/08/2006 and 02/22/2007 Defect: on certain passenger vehicles, the front door latch cable may become partially unseated from the interior release handle housing causing the door latch to stick in the open position and not be secured to the striker. Consequence: during certain crash conditions, the possibility of a door opening could cause an unbelted passenger to be ejected, increasing the risk of injuries. Action: this action is superseded (please see 07-v414.) dealers will add free of charge a secondary feature to both front doors to prevent the door latch cable ferrule from becoming unseated at the interior front door release handle housing. the recall began on april 30, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/15/2007 | |
| CALIBER RECALLS | Top |
| 2007 DODGE CALIBER Manufactured between: 11/29/2006 and 03/13/2007 Defect: certain passenger vehicles equipped with rear disc brakes fail to conform to the requirements of federal motor vehicle safety standard (fmvss) no. 135, "light vehicle brake systems." the length of the rear wheel hub mounting bolts may prevent actuation of the park brake. Consequence: this could allow unintended movement of the vehicle under certain conditions and cause a crash without warning. Action: dealers will replace the rear wheel hub mounting bolts and repair the park brake free of charge. the recall began on may 8, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 05/07/2007 | |
| 2007 DODGE CALIBER Manufactured between: 09/07/2006 and 12/13/2006 Defect: on certain vehicles, the antilock brake system (abs) control module software may cause the rear brakes to lock up during certain braking conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will reprogram the abs electronic control unit. the recall began on february 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 12/29/2006 | |
| CARAVAN RECALLS | Top |
| 2006 DODGE CARAVAN Manufactured between: 09/27/2005 and 12/13/2005 Defect: on certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break. Consequence: during certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash. Action: dealers will inspect and replace the windshield wiper motor free of charge. the recall began on june 19, 2006, to dodge durango owners. minivan owners will be notified during july 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/08/2006 | |
| 2005 DODGE CARAVAN Manufactured between: 04/24/2003 and 02/02/2005 Defect: certain minivans are being recalled that were originally sold in or currently registered in the 27 states plus the district of columbia that use greater amounts of salt for winter road deicing. the up-front (uf) air bag sensors that contain brass bushings installed in these vehicles may corrode and crack allowing water to enter the sensor. these sensors provide enhanced air bag performance in certain types of frontal crashes. Consequence: in one of these crashes, with one or both of the vehicle¿s uf sensors inoperative, the occupants will not benefit from the enhanced air bag protection that these sensors would provide. Action: for vehicles registered in the recall states, dealers will replace the original uf air bag sensors with ones with greater corrosion resistance. vehicles registered in other states will obtain a lifetime free replacement of any uf sensor that fails. the campaign began on july 2, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 05/03/2007 | |
| 2005 DODGE CARAVAN Manufactured between: 03/27/2005 and 07/01/2005 Defect: on certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break. Consequence: during certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash. Action: dealers will inspect and replace the windshield wiper motor free of charge. the recall began on june 19, 2006, to dodge durango owners. minivan owners will be notified during july 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/08/2006 | |
| 2005 DODGE CARAVAN Manufactured between: 10/20/2003 and 01/16/2004 Defect: after performing the ncap test, it was discovered that on certain minivans equipped without the available ¿stow ¿n go¿ seating option, the right front seat belt retractor assembly may have been improperly assembled. Consequence: as a result, the seat belt may not properly restrain the occupant during certain crash conditions, which can increase the risk of injury. Action: dealers will inspect the retractor assemblies and any seat belt assembly that does not have the stake will be replaced. owner notification began on february 23, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/03/2004 | |
| 2004 DODGE CARAVAN Manufactured between: 10/01/2001 and 08/01/2003 Defect: on certain minivans equipped with 3.3 or 3.8l v-6 engine, the upper power steering cooler hose may split and cause a fluid leak. Consequence: power steering fluid leakage in the presence of an ignition source can result in an under hood fire. Action: dealers will replace the upper power steering cooler hose. this recall began on september 27, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 08/05/2004 | |
| CHARGER RECALLS | Top |
| 2007 DODGE CHARGER Manufactured between: 09/07/2006 and 12/13/2006 Defect: on certain vehicles, the antilock brake system (abs) control module software may cause the rear brakes to lock up during certain braking conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will reprogram the abs electronic control unit. the recall began on february 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 12/29/2006 | |
| 2007 DODGE CHARGER Manufactured between: 07/01/2006 and 08/11/2006 Defect: on certain passenger and sport utility vehicles and pickup trucks equipped with automatic transmissions, the software programmed into the powertrain control module can cause a momentary lock up of the drive wheels if the vehicle is traveling over 40 mph and the operator shifts from drive to neutral and back to drive. Consequence: if the drive wheels locked up, loss of vehicle control could occur increasing the risk of a crash. Action: dealers will reprogram the powertrain control module free of charge. the recall began on october 2, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/07/2006 | |
| 2006 DODGE CHARGER Manufactured between: 06/01/2005 and 02/20/2006 Defect: certain passenger vehicles equipped with 2.7 liter engines and mk25e braking systems may exhibit inadequate clearance between the rear brake tubes and the exhaust gas recirculation tube. contact between the brake tubes and exhaust gas recirculation tube over an extended period of time may cause the brake tubes to wear through and cause a brake fluid leak. Consequence: this can result in a decrease of braking force and the potential for an engine compartment fire. Action: dealers will inspect the rear brake tubes for damage and replace them free of charge. a clip will also be installed to secure the brake tubes to the right front shock tower to maintain proper clearance to the exhaust gas recirculation tube. the recall began on june 26, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 05/03/2006 | |
| 2006 DODGE CHARGER Manufactured between: 02/02/2005 and 08/17/2005 Defect: on certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. if the shaft moves out of position, the vehicle may not be able to achieve 'park' position. Consequence: if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning. Action: dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. the recall began on november 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| DAKOTA RECALLS | Top |
| 2007 DODGE DAKOTA Manufactured between: 07/01/2006 and 08/11/2006 Defect: on certain passenger and sport utility vehicles and pickup trucks equipped with automatic transmissions, the software programmed into the powertrain control module can cause a momentary lock up of the drive wheels if the vehicle is traveling over 40 mph and the operator shifts from drive to neutral and back to drive. Consequence: if the drive wheels locked up, loss of vehicle control could occur increasing the risk of a crash. Action: dealers will reprogram the powertrain control module free of charge. the recall began on october 2, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/07/2006 | |
| 2006 DODGE DAKOTA Manufactured between: 09/13/2005 and 12/09/2005 Defect: on certain pickup trucks equipped with four-wheel antilock brake systems (abs), the abs electronic control unit (ecu) may cause a loss of front to rear brake balance, and the rear brakes could lock up prematurely during certain braking conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will replace the abs ecu. the recall is expected to begin during the week of july 17, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/09/2006 | |
| 2006 DODGE DAKOTA Manufactured between: 07/01/2005 and 01/27/2006 Defect: on certain pickup trucks and sport utility vehicles, a static electricity spark between the operator and the vehicle can cause the turn signal, headlamps or windshield wipers to malfunction without warning. Consequence: this can impair the driver's vision and result in a crash. Action: dealers will re-flash the instrument cluster. the recall began on march 6, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/09/2006 | |
| 2005 DODGE DAKOTA Manufactured between: 09/01/2004 and 06/01/2005 Defect: on certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. if the shaft moves out of position, the vehicle may not be able to achieve 'park' position. Consequence: if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning. Action: dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. the recall began on november 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2005 DODGE DAKOTA Manufactured between: 07/01/2004 and 11/23/2004 Defect: on certain pickup trucks equipped with the optional side curtain air bag, the curtain fasteners may not have been properly tightened. Consequence: this could result in an improper side air bag curtain deployment in certain side crash conditions, which can increase the risk of injury to vehicle occupants. Action: dealers will tighten the side air bag curtain fasteners to the proper specification. the recall began on january 17, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 01/05/2005 | |
| 2004 DODGE DAKOTA Manufactured between: 04/24/2002 and 09/15/2003 Defect: on certain pickup trucks and sport utility vehicles, the windshield wiper module motor may be susceptible to water intrusion that could cause internal corrosion and result in partial or complete loss of front windshield wiping capability. Consequence: driver visibility could be reduced, which could result in a crash. Action: dealers will replace the front windshield wiper module. owner notification began on july 12, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 05/05/2004 | |
| DURANGO RECALLS | Top |
| 2007 DODGE DURANGO Manufactured between: 07/24/2006 and 09/01/2006 Defect: on certain vehicles, the right front steering knuckle may have been improperly manufactured. because of a broken cooling line, parts cast in tool cavity #63 on july 18 and july 19, 2006, may have a cold shut condition and could fracture. Consequence: this could cause a loss of steering control and result in a crash without warning. Action: dealers will inspect the recalled vehicles to identify the defective parts and replace if they are within that lot. the recall began on november 8, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/11/2006 | |
| 2007 DODGE DURANGO Manufactured between: 07/01/2006 and 08/11/2006 Defect: on certain passenger and sport utility vehicles and pickup trucks equipped with automatic transmissions, the software programmed into the powertrain control module can cause a momentary lock up of the drive wheels if the vehicle is traveling over 40 mph and the operator shifts from drive to neutral and back to drive. Consequence: if the drive wheels locked up, loss of vehicle control could occur increasing the risk of a crash. Action: dealers will reprogram the powertrain control module free of charge. the recall began on october 2, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/07/2006 | |
| 2006 DODGE DURANGO Manufactured between: 04/03/2003 and 06/30/2006 Defect: on some sport utility vehicles, under certain operating conditions, an integrated circuit in the instrument cluster that controls interior lighting may overheat. Consequence: this could potentially cause an instrument panel fire. Action: dealers will inspect the cluster for damage and replace it free of charge. the recall began on april 2, 2007. owners may contact daimlerchrysler at 1-800-853-140. Recall Date: 03/09/2007 | |
| 2006 DODGE DURANGO Manufactured between: 05/15/2006 and 05/16/2006 Defect: on certain sport utility vehicles, the left rear suspension watts link may have been damaged during vehicle assembly and could fail. Consequence: a failed watts link could adversely affect vehicle handling and cause a crash without warning. Action: dealers will replace the left rear suspension watts link free of charge. the recall began on july 19, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 07/07/2006 | |
| 2006 DODGE DURANGO Manufactured between: 09/27/2005 and 11/24/2005 Defect: on certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break. Consequence: during certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash. Action: dealers will inspect and replace the windshield wiper motor free of charge. the recall began on june 19, 2006, to dodge durango owners. minivan owners will be notified during july 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/08/2006 | |
| 2006 DODGE DURANGO Manufactured between: 01/13/2006 and 01/18/2006 Defect: certain sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 208, 'occupant crash protection.' the wrong occupant restraint controller (orc) was installed on these vehicles. Consequence: this can cause increased risk of injury to the driver under certain crash conditions. Action: dealers will replace the occupant restraint control module. the recall began on february 27, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/13/2006 | |
| 2006 DODGE DURANGO Manufactured between: 07/01/2005 and 01/27/2006 Defect: on certain pickup trucks and sport utility vehicles, a static electricity spark between the operator and the vehicle can cause the turn signal, headlamps or windshield wipers to malfunction without warning. Consequence: this can impair the driver's vision and result in a crash. Action: dealers will re-flash the instrument cluster. the recall began on march 6, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/09/2006 | |
| 2006 DODGE DURANGO Manufactured between: 07/08/2005 and 09/30/2005 Defect: on certain sport utility vehicles with anti-lock brake system (abs), the abs control module software program may cause the rear brakes to lock up during certain braking conditions. Consequence: this could result in a loss of vehicle control and a crash could occur without warning. Action: dealers will reprogram the abs control module. the recall is expected to begin on december 12, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 12/08/2005 | |
| 2006 DODGE DURANGO Manufactured between: 10/06/2004 and 05/23/2005 Defect: on certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. if the shaft moves out of position, the vehicle may not be able to achieve 'park' position. Consequence: if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning. Action: dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. the recall began on november 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2005 DODGE DURANGO Manufactured between: 04/03/2003 and 06/30/2006 Defect: on some sport utility vehicles, under certain operating conditions, an integrated circuit in the instrument cluster that controls interior lighting may overheat. Consequence: this could potentially cause an instrument panel fire. Action: dealers will inspect the cluster for damage and replace it free of charge. the recall began on april 2, 2007. owners may contact daimlerchrysler at 1-800-853-140. Recall Date: 03/09/2007 | |
| 2005 DODGE DURANGO Manufactured between: 03/27/2005 and 06/12/2005 Defect: on certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break. Consequence: during certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash. Action: dealers will inspect and replace the windshield wiper motor free of charge. the recall began on june 19, 2006, to dodge durango owners. minivan owners will be notified during july 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/08/2006 | |
| 2005 DODGE DURANGO Manufactured between: 09/01/2004 and 06/01/2005 Defect: on certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. if the shaft moves out of position, the vehicle may not be able to achieve 'park' position. Consequence: if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning. Action: dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. the recall began on november 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2005 DODGE DURANGO Manufactured between: 03/01/2004 and 11/16/2004 Defect: on certain sport utility vehicles, the fuel tank filler tube inlet check valve may not fully close at the end of refueling. this could allow some fuel to escape from the vehicle filler neck. Consequence: fuel leakage in the presence of an ignition source can result in a fire. Action: dealers will inspect the inlet check valves and replace the fuel tank assembly free of charge. the recall began on april 4, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/03/2005 | |
| 2004 DODGE DURANGO Manufactured between: 04/03/2003 and 06/30/2006 Defect: on some sport utility vehicles, under certain operating conditions, an integrated circuit in the instrument cluster that controls interior lighting may overheat. Consequence: this could potentially cause an instrument panel fire. Action: dealers will inspect the cluster for damage and replace it free of charge. the recall began on april 2, 2007. owners may contact daimlerchrysler at 1-800-853-140. Recall Date: 03/09/2007 | |
| 2004 DODGE DURANGO Manufactured between: 07/21/2003 and 07/01/2004 Defect: on certain sport utility vehicles built with a 5.7l, 4.7l, or 3.7l engine, the positive battery cable may contact the front suspension upper control arm mounting bracket. Consequence: this contact could abrade the cable and cause a short circuit, which may result in an underhood fire. Action: dealers will inspect the battery cable and, if necessary, reposition it away from the control arm mounting bracket. the recall began december 14, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 12/08/2004 | |
| 2004 DODGE DURANGO Manufactured between: 04/03/2003 and 01/08/2004 Defect: on certain sport utility vehicles equipped with 3.7l and 4.7l engines, the throttle control cable may ingest water and freeze during extended cold temperature. Consequence: this could cause the throttle to stick in the open position and result in a crash. Action: dealers will replace the throttle control cable. owner notification began on january 19, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 01/14/2004 | |
| 2004 DODGE DURANGO Manufactured between: 04/03/2003 and 12/07/2003 Defect: on certain sport utility vehicles, an instrument cluster circuit board capacitor may overheat. Consequence: this could potentially result in an instrument panel fire. Action: dealers will remove the capacitor from the circuit board. owner notification began on december 17, 2003. owners should contact daimlerchrysler at 1-800-992-1997. Recall Date: 12/12/2003 | |
| GRAND CARAVAN RECALLS | Top |
| 2006 DODGE GRAND CARAVAN Manufactured between: 09/27/2005 and 12/13/2005 Defect: on certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break. Consequence: during certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash. Action: dealers will inspect and replace the windshield wiper motor free of charge. the recall began on june 19, 2006, to dodge durango owners. minivan owners will be notified during july 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/08/2006 | |
| 2005 DODGE GRAND CARAVAN Manufactured between: 03/27/2005 and 07/01/2005 Defect: on certain vans and sport utility vehicles, the front windshield wiper motor armature shaft may break. Consequence: during certain operating conditions, loss of front windshield wiping capability could occur, and the driver's vision could be obscured which could result in a crash. Action: dealers will inspect and replace the windshield wiper motor free of charge. the recall began on june 19, 2006, to dodge durango owners. minivan owners will be notified during july 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/08/2006 | |
| 2005 DODGE GRAND CARAVAN Manufactured between: 10/20/2003 and 01/16/2004 Defect: after performing the ncap test, it was discovered that on certain minivans equipped without the available ¿stow ¿n go¿ seating option, the right front seat belt retractor assembly may have been improperly assembled. Consequence: as a result, the seat belt may not properly restrain the occupant during certain crash conditions, which can increase the risk of injury. Action: dealers will inspect the retractor assemblies and any seat belt assembly that does not have the stake will be replaced. owner notification began on february 23, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/03/2004 | |
| 2004 DODGE GRAND CARAVAN Manufactured between: 10/01/2001 and 08/01/2003 Defect: on certain minivans equipped with 3.3 or 3.8l v-6 engine, the upper power steering cooler hose may split and cause a fluid leak. Consequence: power steering fluid leakage in the presence of an ignition source can result in an under hood fire. Action: dealers will replace the upper power steering cooler hose. this recall began on september 27, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 08/05/2004 | |
| MAGNUM RECALLS | Top |
| 2007 DODGE MAGNUM Manufactured between: 09/07/2006 and 12/13/2006 Defect: on certain vehicles, the antilock brake system (abs) control module software may cause the rear brakes to lock up during certain braking conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will reprogram the abs electronic control unit. the recall began on february 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 12/29/2006 | |
| 2007 DODGE MAGNUM Manufactured between: 07/01/2006 and 08/11/2006 Defect: on certain passenger and sport utility vehicles and pickup trucks equipped with automatic transmissions, the software programmed into the powertrain control module can cause a momentary lock up of the drive wheels if the vehicle is traveling over 40 mph and the operator shifts from drive to neutral and back to drive. Consequence: if the drive wheels locked up, loss of vehicle control could occur increasing the risk of a crash. Action: dealers will reprogram the powertrain control module free of charge. the recall began on october 2, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/07/2006 | |
| 2006 DODGE MAGNUM Manufactured between: 06/01/2005 and 02/20/2006 Defect: certain passenger vehicles equipped with 2.7 liter engines and mk25e braking systems may exhibit inadequate clearance between the rear brake tubes and the exhaust gas recirculation tube. contact between the brake tubes and exhaust gas recirculation tube over an extended period of time may cause the brake tubes to wear through and cause a brake fluid leak. Consequence: this can result in a decrease of braking force and the potential for an engine compartment fire. Action: dealers will inspect the rear brake tubes for damage and replace them free of charge. a clip will also be installed to secure the brake tubes to the right front shock tower to maintain proper clearance to the exhaust gas recirculation tube. the recall began on june 26, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 05/03/2006 | |
| 2006 DODGE MAGNUM Manufactured between: 07/31/2004 and 08/17/2005 Defect: on certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. if the shaft moves out of position, the vehicle may not be able to achieve 'park' position. Consequence: if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning. Action: dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. the recall began on november 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2005 DODGE MAGNUM Manufactured between: 09/01/2004 and 06/01/2005 Defect: on certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. if the shaft moves out of position, the vehicle may not be able to achieve 'park' position. Consequence: if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning. Action: dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. the recall began on november 28, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2005 DODGE MAGNUM Manufactured between: 01/02/2004 and 04/21/2004 Defect: on certain passenger vehicles, the battery cable fasteners at the bulkhead stud may not have been properly tightened. Consequence: a loose fastener can cause an instrument panel fire. Action: dealers will tighten the bulkhead stud battery cable fasteners to the proper specification. owner notification began on july 6, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 07/09/2004 | |
| 2005 DODGE MAGNUM Manufactured between: 12/01/2003 and 05/01/2004 Defect: on certain passenger vehicles, the front shoulder belt adjustable turning loop (atl) bolts may not have been properly tightened. Consequence: this could cause shoulder belt separation in certain crash conditions, which can increase the risk of injury to front seat occupants. Action: dealers will tighten the shoulder belt adjuster turning loop bolts to the proper specification. owner notification began on july 6, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 07/08/2004 | |
| 2005 DODGE MAGNUM Manufactured between: 05/14/2004 and 05/16/2004 Defect: on certain passenger vehicles, a spot welding operation for the rear floorpan reinforcement may not have been performed. Consequence: this could cause the rear seat belt anchors and/or the child seat anchors to separate in certain crash conditions, which can increase the risk of injury to rear seat passengers. Action: dealers will inspect the rear floorpan reinforcement for missing welds and install structural rivets if necessary. owner notification began on july 6, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 07/08/2004 | |
| NITRO RECALLS | Top |
| 2007 DODGE NITRO Manufactured between: 01/31/2005 and 07/12/2007 Defect: on certain sport utility vehicles, the software programmed into the abs electronic control module may allow a momentary delay in braking when coasting up a hill during certain conditions. Consequence: this could cause a crash without warning. Action: dealers will reprogram the abs electronic control module with new software that prevents this condition free of charge. the recall began on october 22, 2007. owners may contact chrysler at 1-800-853-1403. Recall Date: 09/14/2007 | |
| 2007 DODGE NITRO Manufactured between: 01/30/2006 and 01/22/2007 Defect: on certain vehicles, the totally integrated power module (tipm) was programmed with software that may allow the engine to stall under certain operating conditions. Consequence: this could cause a crash without warning. Action: dealers will reprogram the tipm. the recall began on july 5, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 07/03/2007 | |
| 2007 DODGE NITRO Manufactured between: 09/07/2006 and 12/13/2006 Defect: on certain vehicles, the antilock brake system (abs) control module software may cause the rear brakes to lock up during certain braking conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will reprogram the abs electronic control unit. the recall began on february 19, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 12/29/2006 | |
| NITRO 4X2 RECALLS | Top |
| 2007 DODGE NITRO 4X2 Manufactured between: 07/01/2006 and 08/11/2006 Defect: on certain passenger and sport utility vehicles and pickup trucks equipped with automatic transmissions, the software programmed into the powertrain control module can cause a momentary lock up of the drive wheels if the vehicle is traveling over 40 mph and the operator shifts from drive to neutral and back to drive. Consequence: if the drive wheels locked up, loss of vehicle control could occur increasing the risk of a crash. Action: dealers will reprogram the powertrain control module free of charge. the recall began on october 2, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/07/2006 | |
| RAM RECALLS | Top |
| 2007 DODGE RAM Manufactured between: 07/01/2006 and 11/06/2006 Defect: on certain two wheel drive trucks equipped with manual transmissions, the front driveshaft yoke may break under certain driving conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will replace the driveshaft free of charge. the recall began on october 22, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/12/2007 | |
| 2004 DODGE RAM Manufactured between: 06/22/2004 and 07/07/2004 Defect: on certain pick-up trucks equipped with 4.7l engines, the generator wiring harness may short circuit due to contact with a valve cover stud. Consequence: a short circuit in the generator harness can cause an under hood fire. Action: dealers will inspect the alternator wiring insulation for damage and repair and add a tie-strap clip to the valve cover stud to retain the wiring. this recall began on august 13, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 08/03/2004 | |
| RAM 1500 RECALLS | Top |
| 2006 DODGE RAM 1500 Manufactured between: 11/07/2005 and 04/27/2006 Defect: on certain pickup trucks, the front wheel bearing may have received an insufficient quantity of grease during the manufacturing process. Consequence: this could result in bearing degradation, and if subsequent noise and vibration are ignored, could result in hub assembly separation. this may result in a loss of vehicle control and cause a crash without warning. Action: dealers will replace the front hub and bearing units. the recall began on february 26, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/12/2007 | |
| 2006 DODGE RAM 1500 Manufactured between: 09/20/2006 and 06/30/2006 Defect: on certain pickup trucks fail to conform to the requirements of federal motor vehicle safety standard no. 208, 'occupant crash protection. the passenger air bag may deploy with excessive force when certain model rear facing child seats are installed in the right front passenger seat position. Consequence: this can increase the risk of injury to a child seat occupant during certain crash conditions. Action: dealers will replace the passenger air bag cushion and reprogram the occupant restraint controller. the recall began on october 20, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/14/2006 | |
| 2006 DODGE RAM 1500 Manufactured between: 02/07/2005 and 06/30/2006 Defect: certain pickup trucks fail to conform to the requirements of federal motor vehicle safety standard no. 208, ¿occupant crash protection.¿ the front passenger seat belt may not be able to tighten securely on certain model child seats. Consequence: this can increase the risk of injury to a child seat occupant in the event of a crash. Action: dealers will replace the front passenger seat belt. the recall began on october 20, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/14/2006 | |
| 2006 DODGE RAM 1500 Manufactured between: 09/12/2005 and 12/11/2005 Defect: on certain pickup trucks equipped with four-wheel antilock brake systems (abs), the abs electronic control unit (ecu) may cause a loss of front to rear brake balance, and the rear brakes could lock up prematurely during certain braking conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will replace the abs ecu. the recall is expected to begin during the week of july 17, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/09/2006 | |
| 2006 DODGE RAM 1500 Manufactured between: 02/09/2005 and 09/07/2005 Defect: on certain 4-wheel drive pickup trucks, the totally integrated power module (tipm) may contain incorrect transfer case calibration set points, potentially resulting in inadvertent transfer case default to neutral. Consequence: if this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning. Action: dealers will reprogram the tipm with new software that prevents the potential for this condition. the recall began on november 7, 2005. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2004 DODGE RAM 1500 Manufactured between: 01/20/2004 and 02/13/2004 Defect: the vehicle certification label on some pickup trucks lists incorrect tire, wheel, and recommended inflation pressure information which does not conform to the requirements of federal motor vehicle safety standard no. 120, 'tire selection and rims for vehicles other than passenger cars.' Consequence: installing the incorrect tire/rim sizes and loading the vehicle to the weights shown on the label can cause tire failure and result in a crash without warning. Action: owners will be provided with vehicle certification label overlays containing the corrected information relative to vehicle tire and rim size, and recommended inflation pressure. this recall began on may 5, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 05/06/2004 | |
| 2004 DODGE RAM 1500 Manufactured between: 11/05/2003 and 11/06/2003 Defect: on certain pickup trucks, the transfer case to transmission attaching fasteners may not be tightened correctly. this could cause the transmission adapter or transfer case housing to crack and leak fluid. Consequence: continued operation can result in propeller shaft separation and damage to fuel system components, which could lead to a fuel leak. fluid and/or fuel leakage in the presence of an ignition source can cause an underbody fire. Action: dealers will retighten the transfer case to transmission fasteners. owner notification began on december 22, 2003. owners should contact daimlerchrysler at 1-800-992-1997. Recall Date: 12/04/2003 | |
| RAM 2500 RECALLS | Top |
| 2007 DODGE RAM 2500 Manufactured between: 04/25/2006 and 04/23/2007 Defect: certain pickup trucks equipped with 34 gallon fuel tanks fail to comply with the requirements of federal motor vehicle safety standard no. 301, "fuel system integrity." the fuel tank may become damaged during certain crash conditions, which could allow fuel leakage to occur if the vehicle rolls over. Consequence: fuel leakage, in the presence of an ignition source, could result in a fire. Action: dealers will install a fuel tank shield onto the front frame cross member. the recall began on june 12, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 06/13/2007 | |
| 2007 DODGE RAM 2500 Manufactured between: 11/27/2006 and 12/22/2006 Defect: certain 4x4 trucks with diesel engines fail to conform to the requirements of federal motor vehicle safety standard no. 120, certain 4x4 trucks with diesel engines fail to conform to the requirements of federal motor vehicle safety standard no. 120, ¿tire selection and rims for motor vehicles other than passenger cars.¿ the certification label, tire and loading information label and supplemental tire pressure information label contain incorrect tire inflation pressure information. Consequence: improper tire inflation pressure can cause tire failure and result in a crash without warning. Action: dealers will install the correct certification label overlay free of charge. the recall began on march 12, 2007. owners may contact daimlerchryler at 1-800-853-1403. Recall Date: 03/12/2007 | |
| 2006 DODGE RAM 2500 Manufactured between: 09/12/2005 and 12/11/2005 Defect: on certain pickup trucks equipped with four-wheel antilock brake systems (abs), the abs electronic control unit (ecu) may cause a loss of front to rear brake balance, and the rear brakes could lock up prematurely during certain braking conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will replace the abs ecu. the recall is expected to begin during the week of july 17, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/09/2006 | |
| 2005 DODGE RAM 2500 Manufactured between: 06/01/2002 and 07/31/2005 Defect: on certain pickup trucks equipped with diesel engines and automatic transmissions, in an attempt to exit the vehicle quickly without shutting off the engine and removing the key, the driver may inadvertently leave the automatic transmission shift control in indicated reverse. Consequence: this error is an unintended action that may result in a lack of transmission park pawl engagement and possibly delayed rearward movement of the vehicle. Action: dealers will perform a software modification to equip these vehicles with an out-of-park alarm. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2004 DODGE RAM 2500 Manufactured between: 06/01/2002 and 07/31/2005 Defect: on certain pickup trucks equipped with diesel engines and automatic transmissions, in an attempt to exit the vehicle quickly without shutting off the engine and removing the key, the driver may inadvertently leave the automatic transmission shift control in indicated reverse. Consequence: this error is an unintended action that may result in a lack of transmission park pawl engagement and possibly delayed rearward movement of the vehicle. Action: dealers will perform a software modification to equip these vehicles with an out-of-park alarm. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2004 DODGE RAM 2500 Manufactured between: 01/20/2004 and 02/13/2004 Defect: the vehicle certification label on some pickup trucks lists incorrect tire, wheel, and recommended inflation pressure information which does not conform to the requirements of federal motor vehicle safety standard no. 120, 'tire selection and rims for vehicles other than passenger cars.' Consequence: installing the incorrect tire/rim sizes and loading the vehicle to the weights shown on the label can cause tire failure and result in a crash without warning. Action: owners will be provided with vehicle certification label overlays containing the corrected information relative to vehicle tire and rim size, and recommended inflation pressure. this recall began on may 5, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 05/06/2004 | |
| 2004 DODGE RAM 2500 Manufactured between: 11/05/2003 and 11/06/2003 Defect: on certain pickup trucks, the transfer case to transmission attaching fasteners may not be tightened correctly. this could cause the transmission adapter or transfer case housing to crack and leak fluid. Consequence: continued operation can result in propeller shaft separation and damage to fuel system components, which could lead to a fuel leak. fluid and/or fuel leakage in the presence of an ignition source can cause an underbody fire. Action: dealers will retighten the transfer case to transmission fasteners. owner notification began on december 22, 2003. owners should contact daimlerchrysler at 1-800-992-1997. Recall Date: 12/04/2003 | |
| RAM 3500 RECALLS | Top |
| 2007 DODGE RAM 3500 Manufactured between: 02/24/2006 and 06/28/2007 Defect: on certain cab/chassis pickup trucks equipped with an optional 23 gallon fuel tank, the fuel tank straps were improperly manufactured and could separate. this can cause the fuel tank to loosen and leak fuel. Consequence: fuel leakage in the presence of an ignition source can result in an underbody fire. Action: dealers will replace the fuel tank retention straps and fasteners free of charge. the recall began on november 12, 2007. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/09/2007 | |
| 2007 DODGE RAM 3500 Manufactured between: 12/23/2005 and 09/08/2006 Defect: certain trucks fail to conform to the requirements of federal motor vehicle safety standard no. 111, "rear view mirrors". the right outside rear view mirror glass has a curved (convex) mirror glass installed instead of flat glass. curved glass creates a wider view, but displays images further away than they actually are. Consequence: drivers of large vehicles may have difficulty judging distance relationships, which could cause a crash without prior warning. Action: dealers will replace the right outside convex mirror glass with a flat mirror glass free of charge. the recall began on october 10, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/10/2006 | |
| 2007 DODGE RAM 3500 Manufactured between: 07/01/2006 and 08/11/2006 Defect: on certain passenger and sport utility vehicles and pickup trucks equipped with automatic transmissions, the software programmed into the powertrain control module can cause a momentary lock up of the drive wheels if the vehicle is traveling over 40 mph and the operator shifts from drive to neutral and back to drive. Consequence: if the drive wheels locked up, loss of vehicle control could occur increasing the risk of a crash. Action: dealers will reprogram the powertrain control module free of charge. the recall began on october 2, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 09/07/2006 | |
| 2006 DODGE RAM 3500 Manufactured between: 12/23/2005 and 09/08/2006 Defect: certain trucks fail to conform to the requirements of federal motor vehicle safety standard no. 111, "rear view mirrors". the right outside rear view mirror glass has a curved (convex) mirror glass installed instead of flat glass. curved glass creates a wider view, but displays images further away than they actually are. Consequence: drivers of large vehicles may have difficulty judging distance relationships, which could cause a crash without prior warning. Action: dealers will replace the right outside convex mirror glass with a flat mirror glass free of charge. the recall began on october 10, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/10/2006 | |
| 2006 DODGE RAM 3500 Manufactured between: 12/23/2005 and 02/15/2006 Defect: certain trucks equipped with dual rear wheels fail to comply with the requirements of federal motor vehicle safety standard no. 108, ¿lamps, reflective devices and associated equipment.¿ the trucks may have been inadvertently manufactured without the roof mounted cab clearance lamps. Consequence: without these lamps, other vehicle operators may not detect the increased width of the vehicle which could cause a crash without warning. Action: dealers will install cab clearance lights free of charge. the recall began on march 20, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 03/09/2006 | |
| 2006 DODGE RAM 3500 Manufactured between: 09/12/2005 and 12/11/2005 Defect: on certain pickup trucks equipped with four-wheel antilock brake systems (abs), the abs electronic control unit (ecu) may cause a loss of front to rear brake balance, and the rear brakes could lock up prematurely during certain braking conditions. Consequence: this could result in a loss of vehicle control and cause a crash without warning. Action: dealers will replace the abs ecu. the recall is expected to begin during the week of july 17, 2006. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 02/09/2006 | |
| 2005 DODGE RAM 3500 Manufactured between: 06/01/2002 and 07/31/2005 Defect: on certain pickup trucks equipped with diesel engines and automatic transmissions, in an attempt to exit the vehicle quickly without shutting off the engine and removing the key, the driver may inadvertently leave the automatic transmission shift control in indicated reverse. Consequence: this error is an unintended action that may result in a lack of transmission park pawl engagement and possibly delayed rearward movement of the vehicle. Action: dealers will perform a software modification to equip these vehicles with an out-of-park alarm. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| 2004 DODGE RAM 3500 Manufactured between: 06/01/2002 and 07/31/2005 Defect: on certain pickup trucks equipped with diesel engines and automatic transmissions, in an attempt to exit the vehicle quickly without shutting off the engine and removing the key, the driver may inadvertently leave the automatic transmission shift control in indicated reverse. Consequence: this error is an unintended action that may result in a lack of transmission park pawl engagement and possibly delayed rearward movement of the vehicle. Action: dealers will perform a software modification to equip these vehicles with an out-of-park alarm. owners may contact daimlerchrysler at 1-800-853-1403. Recall Date: 10/06/2005 | |
| SPRINTER RECALLS | Top |
| 2007 DODGE SPRINTER Manufactured between: 09/18/2006 and 04/21/2007 Defect: on certain trucks, the side window air bag module diffuser material may contain hairline cracks. Consequence: in the case of a crash with a trigger signal for the window bag module, it is possible that such a diffuser may crack at the beginning of the air bag activation increasing the risk of injury to the seat occupant. Action: dealers will replace the right, left, or both side window air bag modules. the recall began on july 16, 2007. owners may contact dcc at 1-843-695-5041. Recall Date: 06/07/2007 | |
| SPRINTER 2500 RECALLS | Top |
| 2008 DODGE SPRINTER 2500 Manufactured between: 08/25/2006 and 01/14/2008 Defect: chrysler/sprinter is recalling 727 my 2007-2008 dodge and freightliner sprinter 2500 passenger vans equipped with 144 inch wheelbase and standard roof height. these vans fail to comply with the requirements of federal motor vehicle safety standard no. 201u, 'occupant protection in interior impact.' some vans may not have had certain head impact protection pads installed at the c-pillar. Consequence: in the event of a vehicle crash, personal injury to occupants may occur. Action: dealers will inspect the vehicles and, if the head impact protection pads are missing, the appropriate pads will be installed. the recall began on april 9, 2008. owners may contact sprinter at 1-800-853-1403. Recall Date: 03/11/2008 | |
| 2007 DODGE SPRINTER 2500 Manufactured between: 08/25/2006 and 01/14/2008 Defect: chrysler/sprinter is recalling 727 my 2007-2008 dodge and freightliner sprinter 2500 passenger vans equipped with 144 inch wheelbase and standard roof height. these vans fail to comply with the requirements of federal motor vehicle safety standard no. 201u, 'occupant protection in interior impact.' some vans may not have had certain head impact protection pads installed at the c-pillar. Consequence: in the event of a vehicle crash, personal injury to occupants may occur. Action: dealers will inspect the vehicles and, if the head impact protection pads are missing, the appropriate pads will be installed. the recall began on april 9, 2008. owners may contact sprinter at 1-800-853-1403. Recall Date: 03/11/2008 | |
| 2007 DODGE SPRINTER 2500 Manufactured between: 05/01/2006 and 10/31/2007 Defect: on certain utility vans, the crankshaft sensor in certain diesel engines could fail due to separation of bond wires from the lead frame in the sensor. this results in an interruption in the electrical connection in the chip housing of the sensor. Consequence: when this happens, the vehicles may lose power rather than enter a limp-home mode. in addition, the vehicle cannot be restarted after failure of the electrical connection in the sensor, increasing the risk of a crash. Action: dealers will replace the crankshaft sensors. the recall began on march 3, 2008. owners may contact sprinter at 1-800-992-1997. Recall Date: 12/21/2007 | |
| 2007 DODGE SPRINTER 2500 Manufactured between: 09/09/2006 and 03/15/2007 Defect: on certain trucks, the screw bolts of the fuel tank fastening straps may not have been tightened correctly. after normal production process, the vehicles are disassembed for shipment to the us and the bolts may not have been correctly tightened when re-assembled. Consequence: the fuel tank can loosen and leak fuel. fuel leakage in the presence of an ignition source can result in a fire. Action: dealers will replace the screw bolts of the tank fastening straps and the bolts will be tightened with the correct torque. the recall began on october 8, 2007. owners may contact daimlerchrysler international at 843-695-5041. Recall Date: 07/26/2007 | |
| 2006 DODGE SPRINTER 2500 Manufactured between: 01/30/2001 and 10/07/2006 Defect: on certain trucks equipped with rear air conditioning system, the interior lamp is equipped with an 18w lamp and a scattering lens. in extremely hot and humid conditions, the combination of heat and humidity, and the heat from the lamp due to extreme long term operation, can distort the scattering lens. Consequence: the switching contacts of the lamp may cause a short circuit of the rear lamp increasing the risk of a fire. Action: dealers will replace the rear interior lamps free of charge with a modified version which is not subject to the impacts of heat and humidity. the recall began on december 17, 2007. owners may contact daimlerchrysler manufacturing international at 1-843-695-5041. Recall Date: 07/13/2007 | |
| 2005 DODGE SPRINTER 2500 Manufactured between: 01/30/2001 and 10/07/2006 Defect: on certain trucks equipped with rear air conditioning system, the interior lamp is equipped with an 18w lamp and a scattering lens. in extremely hot and humid conditions, the combination of heat and humidity, and the heat from the lamp due to extreme long term operation, can distort the scattering lens. Consequence: the switching contacts of the lamp may cause a short circuit of the rear lamp increasing the risk of a fire. Action: dealers will replace the rear interior lamps free of charge with a modified version which is not subject to the impacts of heat and humidity. the recall began on december 17, 2007. owners may contact daimlerchrysler manufacturing international at 1-843-695-5041. Recall Date: 07/13/2007 | |
| 2004 DODGE SPRINTER 2500 Manufactured between: 01/30/2001 and 10/07/2006 Defect: on certain trucks equipped with rear air conditioning system, the interior lamp is equipped with an 18w lamp and a scattering lens. in extremely hot and humid conditions, the combination of heat and humidity, and the heat from the lamp due to extreme long term operation, can distort the scattering lens. Consequence: the switching contacts of the lamp may cause a short circuit of the rear lamp increasing the risk of a fire. Action: dealers will replace the rear interior lamps free of charge with a modified version which is not subject to the impacts of heat and humidity. the recall began on december 17, 2007. owners may contact daimlerchrysler manufacturing international at 1-843-695-5041. Recall Date: 07/13/2007 | |
| SPRINTER 3500 RECALLS | Top |
| 2008 DODGE SPRINTER 3500 Manufactured between: 12/12/2006 and 01/24/2008 Defect: sprinter is recalling 34 my 2007-2008 dodge and freightliner sprinter 3500 cargo vans. some of these vans may not have had the correct brake components installed. Consequence: this could result in poor braking performance, increasing the risk of a crash. Action: dealers will install the appropriate master brake cylinders and brake fluid reservoirs. the manufacturer has not yet provided an owner notification schedule for this campaign. owners may contact sprinter at 1-800-992-1997. Recall Date: 03/11/2008 | |
| 2007 DODGE SPRINTER 3500 Manufactured between: 12/12/2006 and 01/24/2008 Defect: sprinter is recalling 34 my 2007-2008 dodge and freightliner sprinter 3500 cargo vans. some of these vans may not have had the correct brake components installed. Consequence: this could result in poor braking performance, increasing the risk of a crash. Action: dealers will install the appropriate master brake cylinders and brake fluid reservoirs. the manufacturer has not yet provided an owner notification schedule for this campaign. owners may contact sprinter at 1-800-992-1997. Recall Date: 03/11/2008 | |
| 2007 DODGE SPRINTER 3500 Manufactured between: 05/01/2006 and 10/31/2007 Defect: on certain utility vans, the crankshaft sensor in certain diesel engines could fail due to separation of bond wires from the lead frame in the sensor. this results in an interruption in the electrical connection in the chip housing of the sensor. Consequence: when this happens, the vehicles may lose power rather than enter a limp-home mode. in addition, the vehicle cannot be restarted after failure of the electrical connection in the sensor, increasing the risk of a crash. Action: dealers will replace the crankshaft sensors. the recall began on march 3, 2008. owners may contact sprinter at 1-800-992-1997. Recall Date: 12/21/2007 | |
| 2007 DODGE SPRINTER 3500 Manufactured between: 09/09/2006 and 03/15/2007 Defect: on certain trucks, the screw bolts of the fuel tank fastening straps may not have been tightened correctly. after normal production process, the vehicles are disassembed for shipment to the us and the bolts may not have been correctly tightened when re-assembled. Consequence: the fuel tank can loosen and leak fuel. fuel leakage in the presence of an ignition source can result in a fire. Action: dealers will replace the screw bolts of the tank fastening straps and the bolts will be tightened with the correct torque. the recall began on october 8, 2007. owners may contact daimlerchrysler international at 843-695-5041. Recall Date: 07/26/2007 | |
| STRATUS RECALLS | Top |
| 2005 DODGE STRATUS Manufactured between: 09/08/2004 and 11/05/2004 Defect: on certain sedans and convertible model vehicles, the right steering knuckle may have been damaged during the component manufacturing process. Consequence: this could cause the steering knuckle to crack and separate from the upper control arm, which could result in a crash. Action: dealers will inspect and replace the right steering knuckle. the recall began on december 27, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 12/09/2004 | |
| 2005 DODGE STRATUS Manufactured between: 07/01/2004 and 08/26/2004 Defect: on certain sedans, the left and right rear outboard retractor and turning loop bolts on the seat belts may not have been properly tightened. Consequence: in the event of a crash, the seat occupant may not be properly restrained, increasing the risk of injury. Action: dealers will inspect and tighten the affected fasteners. the recall began on november 15, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 11/02/2004 | |
| 2004 DODGE STRATUS Manufactured between: 04/16/2004 and 06/20/2004 Defect: on certain 2-door passenger vehicles, the fuel return line hose fitting on the electric fuel pump may be improperly molded. Consequence: breakage could result in a leakage of fuel and in the presence of an ignition source, it could result a fire. Action: dealers will replace the fuel pump. the recall will begin on august 9, 2004. owners should contact daimlerchrysler at 1-800-853-1403. Recall Date: 06/29/2004 | |
| 2004 DODGE STRATUS Manufactured between: 07/25/2003 and 09/11/2003 Defect: on certain passenger vehicles, the fuel return line hose fitting on the electric fuel pump may be restricted, causing excessive fuel pressure to build up in the fuel injection system. excessive fuel pressure may result in a leak in the fuel return hose. Consequence: fuel leakage in the presence of an ignition source could result in a fire. Action: dealers will inspect the fuel pump pressure. those vehicles exhibiting higher than normal fuel pump pressure will receive fuel pump modifications. owner notification began on december 15, 2003. owners should contact daimlerchrysler at 1-800-992-1997. Recall Date: 11/04/2003 | |
Recall reports are furnished as a courtesy to our customers and are not represented as complete, definitive or authoritative. |
Copyright ©2006 Ikon Auto |
|
Site Management: Fabien Vegas Corporation
|