Ikon Auto - Manufacturer Recall Data Copyright 2006 Ikon Auto en-us Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls 1440 Defect: on certain passenger vehicles, a front wheel bearing and hub assembly may fracture due to improper heat treatment.
Consequence: if a hub fractures, it may potentially detach from the wheel knuckle, resulting in the wheel being retained only by the brake caliper assembly. as a result, the wheel may separate from the vehicle potentially resulting in a crash.
Action: dealers will inspect both front wheel bearing and hub assemblies and replace them free of charge. the recall began on june 22, 2007. owners may contact ford at 1-800-392-3673.
Manufactured between: 05/16/2007 and 06/25/2007
Recall Date: 06/26/2007
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: certain passenger vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 212, 'windshield mounting.' the windshield may not be properly secured to the vehicle body.
Consequence: if the windshield is not properly retained to the vehicle, wind noise, squeak/rattles and/or water leaks may occur. also, loss of windshield retention may reduce occupant protection in the event of a crash.
Action: dealers will replace the windshield free of charge. the recall began on november 22, 2006. owners may contact ford at 1-800-392-3673.
Manufactured between: 08/28/2006 and 08/29/2006
Recall Date: 11/15/2006
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain passenger vehicles, the battery cable includes a fusible link that may contact and subsequently chafe on a #2 cross member attaching bolt.
Consequence: this condition may result in heat damage and could lead to a fire.
Action: dealers will inspect the fusible link and position it away from the cross member bolt. if the fusible link has already chafed and copper wires have been exposed, the fusible link will be replaced. the recall began on november 18, 2005. owners may contact ford at 1-800-392-3673, or lincoln/mercury at 1-800-521-4140.
Manufactured between: 03/24/2004 and 02/11/2005
Recall Date: 11/09/2005
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain trucks, passenger cars and sport utility vehicles, the windshield wiper motor may have been produced without grease being applied to the output shaft gear.
Consequence: after a period of continuous use on the high speed setting, lack of grease on the output shaft gear may cause the gear to distort or fracture during operation resulting in a loss of wiper function. inoperative wipers under inclement weather conditions could cause a crash due to impaired visibility.
Action: dealers will inspect the wiper motor for the presence of grease and grease the wiper motor gears if necessary. the recall began on november 22, 2005. owners may contact ford at 1-800-392-3673 or lincoln/mercury at 1-800-521-4140.
Manufactured between: 08/29/2005 and 10/17/2005
Recall Date: 11/09/2005
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: certain sport utility vehicles equipped without side air curtains or moonroofs fail to comply with the requirements of federal motor vehicle safety standard no. 201, "occupant protection in interior impact." during testing, the free motion head form registered a measurement above the permitted limit at the left hand a-pillar trim area.
Consequence: in the event of a vehicle crash, personal injury to occupants may occur.
Action: dealers will make modifications to the energy absorbing material located above the headliner in the affected area free of charge. the recall began on may 19, 2006. owners may contact ford at 1-800-392-3673.
Manufactured between: 01/01/2005 and 03/31/2005
Recall Date: 04/07/2006
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: ford is recalling certain model year 2010 fusion, milan, and escape vehicles manufactured from february 27, through march 26, 2010. the park rod guide retention pin may not have been properly installed which fails to conform to the requirement of federal motor vehicle safety standard no. 114, "theft protection and rollaway prevention".
Consequence: a vehicle parked without an engaged park pawl and without an applied parking brake may have unintended movement which may cause a crash.
Action: ford will notify owners and dealers will repair the vehicles free of charge. the safety recall began on may 28, 2010. owners may contact ford motor company customer relationship center at 1-866-436-7332 and for the hearing impaired call 1-800-232-5952 (tdd). representatives are available monday through friday: 8:00am - 5:00pm.
Manufactured between: 02/27/2010 and 03/26/2010
Recall Date: 05/24/2010
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: ford is recalling certain model year 2010 fusion, explorer, explorer sport trac, and mercury milan and mountaineer vehicles manufactured between december 15, 2009 through february 3, 2010 equipped with front seat manual recliners. these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 202, "head restraint." the recliner gear plate teeth may be out of dimension specification which could result in limited pawl to gear plate tooth engagement.
Consequence: in the event of a crash, the seatback and head restraint may move rearward, increasing the risk of injury.
Action: dealers will replace the manual recliners for both power and manual seats free of charge. the safety recall is expected to begin on or before april 30, 2010. owners may contact ford at 1-866-436-7332.
Manufactured between: 12/11/2009 and 02/03/2010
Recall Date: 04/20/2010
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: ford is recalling certain model year 2007 ford five hundred and mercury montego vehicles manufactured from september 5, 2006, through september 11, 2006. the fuel tanks may not have consistent welds between the fuel tank and fuel filler neck spud which can affect the strength of the joint. some fuel tank spud welds may not provide the expected strength in the event of a severe rear impact to the vehicle. an improper weld can result in a crack in the joint which could illuminate the emissions malfunction indicator light, cause a fuel odor, or allow fuel to leak out.
Consequence: fuel leakage, in the presence of an ignition source, could result in a fire.
Action: dealers will replace the fuel tank free of charge. the safety recall began on august 16, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332.
Manufactured between: 09/05/2006 and 09/11/2006
Recall Date: 07/13/2011
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain passenger vehicles currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota, utah, vermont, west virginia, wisconsin, and wyoming. the side door latch mechanisms may experience water intrusion allowing the latch mechanism to freeze in cold weather.
Consequence: as a result, the door latch pawl may not return to the latch position when the door is closed, and the door could open while the vehicle is moving.
Action: dealers will install a shield over the front latches; seal a drain hole in the rear window trim molding on the freestyle rear side doors; and apply grease to all front and rear side-door latch mechanisms free of charge. the recall began on november 8, 2006. owners may contact ford at 1-800-392-3673.
Manufactured between: 02/16/2004 and 06/20/2005
Recall Date: 10/05/2006
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain passenger vehicles, the straps that secure the fuel tank to the vehicle body may break, causing the fuel tank and fuel tank heat shield to drop on the driveshaft (all wheel drive vehicles) or exhaust system (front wheel drive vehicles).
Consequence: if this happens, drivers may notice a noise or a fuel leak. a fuel leak in the presence of an ignition source could result in a fire.
Action: dealers will replace both fuel tank straps. the recall began on december 1, 2005. owners may contact ford at 1-800-392-3673.
Manufactured between: 01/03/2005 and 06/21/2005
Recall Date: 11/09/2005
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain vans equipped with the power liftgate option, the power liftgate motor automatically disengages after the liftgate is powered open.
Consequence: in the event of a liftgate strut malfunction, the liftgate can fall freely with no prior warning. anyone standing beneath the liftgate may be injured if the liftgate falls.
Action: dealers will reprogram the power liftgate module to reduce the likelihood that the liftgate could fall free of charge. the recall began on march 15, 2006. owners may contact ford at 1-800-392-3673.
Manufactured between: 04/13/2004 and 12/13/2005
Recall Date: 03/09/2006
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain vans equipped with the power liftgate option, the power liftgate motor automatically disengages after the liftgate is powered open.
Consequence: in the event of a liftgate strut malfunction, the liftgate can fall freely with no prior warning. anyone standing beneath the liftgate may be injured if the liftgate falls.
Action: dealers will reprogram the power liftgate module to reduce the likelihood that the liftgate could fall free of charge. the recall began on march 15, 2006. owners may contact ford at 1-800-392-3673.
Manufactured between: 04/13/2004 and 12/13/2005
Recall Date: 03/09/2006
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: certain minivans may have been produced with front wheel hub assemblies that were not heat treated correctly. this condition may lead to the development of small cracks in the hub.
Consequence: if the cracks were to progress, this could eventually result in wheel separation. wheel separation may lead to loss of vehicle control, and potentially result in a vehicle crash.
Action: dealers will replace the front hub, rotors, and wheel bearings. the recall began september 20, 2004. owners should contact ford at 1-800-392-3673.
Manufactured between: 02/23/2004 and 05/13/2004
Recall Date: 09/13/2004
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain minivans, the power steering low-pressure line may not be fully seated at the rack and pinion steering gear.
Consequence: if this line becomes disconnected, it may create the potential for fluid to come into contact with the exhaust system, which could result in smoke or fire.
Action: dealers will inspect the power steering low-pressure line to ensure that it is seated properly at the rack and pinion steering gear. owner notification began november 10, 2003. owners should contact ford at 1-800-392-3673.
Manufactured between: 03/24/2003 and 10/27/2003
Recall Date: 11/06/2003
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: ford is recalling certain model year 2010 fusion, explorer, explorer sport trac, and mercury milan and mountaineer vehicles manufactured between december 15, 2009 through february 3, 2010 equipped with front seat manual recliners. these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 202, "head restraint." the recliner gear plate teeth may be out of dimension specification which could result in limited pawl to gear plate tooth engagement.
Consequence: in the event of a crash, the seatback and head restraint may move rearward, increasing the risk of injury.
Action: dealers will replace the manual recliners for both power and manual seats free of charge. the safety recall is expected to begin on or before april 30, 2010. owners may contact ford at 1-866-436-7332.
Manufactured between: 12/11/2009 and 02/03/2010
Recall Date: 04/20/2010
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain sport utility vehicles equipped with the 4.6l engine and 6r transmission, the bolt securing the transmission oil cooler line fittings at the transmission may not have been sufficiently torqued during vehicle assembly. as a result, the bolt may loosen and the transmission oil cooler lines may disengage from the transmission, causing a transmission fluid leak.
Consequence: if leaking transmission fluid contacts the catalytic converter, it may pose a risk of fire.
Action: dealers will inspect and have the transmission cooler line attachment bolt tightened free of charge. the recall began on august 30, 2007. owners may contact ford at 1-800-392-3673.
Manufactured between: 07/23/2007 and 08/14/2007
Recall Date: 09/26/2007
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: on certain trucks, passenger cars and sport utility vehicles, the windshield wiper motor may have been produced without grease being applied to the output shaft gear.
Consequence: after a period of continuous use on the high speed setting, lack of grease on the output shaft gear may cause the gear to distort or fracture during operation resulting in a loss of wiper function. inoperative wipers under inclement weather conditions could cause a crash due to impaired visibility.
Action: dealers will inspect the wiper motor for the presence of grease and grease the wiper motor gears if necessary. the recall began on november 22, 2005. owners may contact ford at 1-800-392-3673 or lincoln/mercury at 1-800-521-4140.
Manufactured between: 09/02/2005 and 10/17/2005
Recall Date: 11/09/2005
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa Defect: certain passenger vehicles equipped with power adjustable seats may have been inadequately welded.
Consequence: the seat may not perform as intended during a crash which could increase the risk of injury.
Action: dealers will replace the upper support assembly on the power seats. the recall began on july 20, 2004. owners should contact ford at 1-800-392-3673.
Manufactured between: 11/17/2003 and 01/15/2004
Recall Date: 07/08/2004
http://www.ikonauto.com - posted on Fri, 11 Nov 2011 01:08:43 EST by Ikon Auto ]]> http://www.ikonauto.com/recalls/mercury_recalls.htm Fri, 11 Nov 2011 01:08:43 EST Automobile Recalls country:usa